Mercedes-Benz Sprinter - Popular Questions, Answers, Tips & Manuals
412
At this website
www.reliable-store.com I found so much of information on how to repair vehicles and technical issues in detail..
Also complete, much better language, and they also have live assistance feature
I have a jcb 527-55
there is a pressure relief valve in the hydraulic pump
if you have no or very little pressure being generated , it may be that that valve is jammed in the open position or the spring controlling it has broken
in any event the basic problem is that the hydraulic pump is not producing a volume sufficient to build up pressure
check the installation of the filter as it may be restricting oil flow to the pump in installed incorrectly
I have a mercedes sprinter
As the vehicle has just had a full service your van shouldn't be suffering those problems and you should return to the repairer and complain bitterly, do a war dance or whatever it takes for them to finish the job and deliver what you paid for.
If your Sprinter is fuel injected and catalysed there will be nothing to adjust but you need to know the CO2 content rises as the engine runs more efficiently while it is the CO level that should fall.
There are many reasons for poor fuel economy other than high exhaust emissions but after a proper full service the vehicle should already be running as efficiently as possible.
Truck only blowing hot air, and getting very hot on dash
I have a 1994 c ckass w202 mine did this it blew hot air all the time realy anoying in the summer lol any way it was the controler that wss at fault the bit on your dash that regulates the temperature if not yhere is a mixture valve under the bonnet itvregulates how much water goes into the heater matrix
Esp light on sprinter 313 2011 cruise control works now and then any clues thks
check the wheel speed sensors wiring and reluctor rings, the electronic suspension system is part of the abs system, the cruise also uses speed signal from the abs system, sounds like you may have a broken link lead to one of the front wheel speed sensors which makes and breaks connection when you move the steering, wheel good luck
10/25/2016 10:46:50 AM •
2011...
•
393 views • 1 helpful votes
Little power when going up hill
Check engine light on? Any fault codes? If no to these questions then you just have an underpowered truck and you will have to live with it or trade up.
How do you reset the service light on a 2005 Mercedes sprinter 311?
All you need to do is disconnect the battery negative side for a minute. That will reset the light but only for a short time if you did not correct the problem that is causing it. You can also take this to an Oreilly auto parts and they will hook up the diagnostics tool for free and turn it off for you.
3/24/2016 11:03:02 PM •
2005...
•
133 views • 1 helpful votes
Code errors
this is the many problems with Merc Benz. These guys have their own Coding system so you have to return to them to get it fixed. They sell you the car but they have many 'gotchas' so you are stuck going to them for maintenance. It should be against the law.
try to find a Merc Benz Forum that may know what those codes mean
1/5/2016 5:27:40 PM •
2014...
•
1,055 views • 0 helpful votes
Engine making hissing sound
Mix a bit of soap and water and spray near the sound to determine from where the sound is coming, and post more information. If it's a gas car, try not to spray much water on wires like spark plugs or coils. Post information like make and model of car. Engine size, turbo or not, diesel or gas? Not much to go on here. Could be a small vacuum leak or a busted manifold, a bad intercooler, who knows with this bit of info?
12/5/2015 4:07:36 AM •
2014...
•
395 views • 0 helpful votes
If I buy a new central locking key for my sprinter can I programme it myself ?
Def not,
Take it to a key cutter with appropriate software to mate it to your spare key
As a second note keep your key bunch light on 2008 sprinter or you'll break the esr ring
Electronic sensor ring - big bucks to fix and lots of downtime. This happened to me.
Esr ring if it goes will leave electronic solenoid in steering lock engaged and once you've had the sprinter put on the back of a truck and taken to main dealer they replace key box and then everything has to be re- paired with ecu
Big big bucks.
But a great van :-)
10/23/2015 6:37:52 AM •
2010...
•
315 views • 1 helpful votes
Not finding what you are looking for?