20 Most Recent 2007 Toyota Hilux 2.7 Questions & Answers


Remove the key from the ignition but keep it handy. Important: Disconnect the negative terminal of the battery for longer than 90 seconds to prevent the risk of having the airbags deploy! Replace the diesel filter (Follow the instructions that can be found in Toyota service manuals (search www). Remove the diesel filter sensor cable (the one on top of the filter assembly). Make sure the new O-rings seat properly. Close the filter assembly by turning the locking ring until it clicks. Bleed the filter assembly by pushing the little plunger thing on the top of the assembly until pumping becomes difficult. Connect the negative back onto the battery. Insert the key in the lock and turn until the dashboard warning lamps come on, but do not start the car yet. Within 3 to 60 seconds of doing this re-connect the diesel flter sensor cable. The light should be extinguished. Obviously there could be another problem causing the light to remain on (not flashing - steady on). If the light is flashing, then you have water in the system and should follow the answer supplied elsewhere by someone else to drain the water. Now start the car and enjoy clean diesel fuel driving. You should really not wait for the light to come on steady before chnaging the filter. Some fanatics believe every 10,000km is the longest you should wait, but this depends on fuel quality, low or high sulfur content, etc. Rather do it more frequently than having to buy new injectors.

2007 Toyota... | Answered on Sep 28, 2019


Normally it would be open/short
But you should check the injector circuit from the
ECU (Engine Control Unit)

2007 Toyota... | Answered on May 13, 2019


Should be inside the fuel tank. Drop the tank or lift the bed to gain access.

2007 Toyota... | Answered on Mar 18, 2019


Here are the torque specs you requested:
MAIN BRG CAPS= 29FT/LBS THEN TIGHTEN AN ADDITIONAL 90 DEGREES in sequence(two step process)
ROD BEARING CAPS= 18 FT/LBS
CYLINDER HEAD BOLTS= 29FT/LBS + 90 degrees + another 90 degrees in sequence from the center out ward, (3 step process).
Please let me know if you have any questions

2007 Toyota... | Answered on May 29, 2017


Take it back to the shop that did the work. It should run completely fine.

2007 Toyota... | Answered on Aug 15, 2016


Because there is a;ways an explosion danger, I would not go there. Just ask a Toyota certified repair centre to solve the problem. You never know what is wrong.
Check your manual, if the airbag can be switched off, when you have a baby on the passengers seat. Perhaps that is the problem.

2007 Toyota... | Answered on Mar 02, 2016


I'm assuming that you followed the lamps advice and replaced the timing belt. This indication comes on automatically every 150000km to remind you to replace the timing belt before it breaks and causes catastrophic engine damage. That being said, here is the procedure to reset the lamp for the next time.e14cc3b3-111d-48e9-ae93-9d93377ba748.jpg

2007 Toyota... | Answered on Sep 11, 2015


The fuel sensor is to blame - need to locate it and replace.

2007 Toyota... | Answered on Aug 19, 2015


you should check your wires make sure they are tight and that they are in good condition you could also check your alternator and make sure it is working properly and check your fuses and make sure none are blown.

2007 Toyota... | Answered on Jun 30, 2015


How long has it been ran since new battery installed ?

2007 Toyota... | Answered on Jun 30, 2015


I just replaced the cyl. Head gaskets in my 97 toyota 4 runner 4cyl. And i having problems to start the engine when is cold, when is hot start like new

2007 Toyota... | Answered on May 31, 2015


The Toyota Hilux D4D KUN26 2008 1KD-FTV diesel requires 6.9 metric liters of oil, though some website recommend 7.4 liters.

2007 Toyota... | Answered on May 25, 2015


2007 2.7L hilux
what country is this car, (1million posts and not 1 said yet)
this is USA forum.
Seventh generation (AN10, AN20; 2005-present) 2.7 L 2TR-FE I4 engine. Gas too.

go to your country Toy dealer
and ask for the factory service manual
read the ignition chapter, and wiring chapters
bingo.


or online books dont have your car, only usa spec cars.
here.
or join a toy forum in your country is a win, big time.

2007 Toyota... | Answered on Feb 14, 2015


its 1 of 2 things.
1: the fuel is low, use a dip stick, if gauge reads ok.
2; or the tank sender is bad, but gauge reads wrong.
3: the guage wire is disconnected, cut or corroded connections.

2007 Toyota... | Answered on Feb 03, 2015


please give me your immobiliser or alarm system info .if is immo system problem when you turn on switch meter will no come out check engine light ,please check it.

2007 Toyota... | Answered on Jan 08, 2015


you will get these from a toyota dealer from their workshop cd manual. However if you want to check the chassis for bends , the dimensions do not need to be known
place the vehicle over a flat floor and using a plumb bob on a sting line drop points onto the floor and mark the position on the floor . Use the same points on each side of the chassis
get as many marks on the floor as possible and put on the floor next to the mark where they came from on the chassis (ie rear spring hanger, foot step bracket , tank bracket etc)
move the vehicle out of the way and with a tape measure measure the diagonals of like points. Write the dimension on the floor on that diagonal. When finished the variations of like diagonals should be no more than 3mm max. The diagonal with the largest variation will indicate exactly where the chassis needs straightening

2007 Toyota... | Answered on Dec 26, 2014

Not finding what you are looking for?
2007 Toyota Hilux 2.7 Logo

145 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Toyota Experts

Marvin
Marvin

Level 3 Expert

85216 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

Jonah Oneal

Level 3 Expert

14092 Answers

Are you a Toyota Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Hilux Toyota

  • Hilux Toyota

Most Popular Question

check engine light showing idling higher

  • Cars & Trucks
Loading...