2004 Chevrolet Express - Answered Questions & Fixed issues


PLEASE DON'T FORGET TO RATE--You didn't post the size of motor so please pick the applicable one:

e8f5627.gif
Accessory serpentine belt routing—4.8L, 5.3L and 6.0L engines

793398d.gif
Accessory serpentine belt routing—4.3L, 5.0L and 5.7L engines without A/C

b701ba4.gif
Accessory serpentine belt routing—4.3L, 5.0L and 5.7L engines with A/C

a8d5a93.gif
Accessory serpentine belt routing—6.5L Diesel engines

7f5d3cb.gif
Accessory serpentine belt routing—7.4L engine

10dba31.gif
Accessory serpentine belt routing—8.1L engine

2004 Chevrolet... | Answered on Dec 21, 2018 | 57,194 views


Striker post

If you need further help, reach me via phone at https://www.6ya.com/expert/ralph_f3d50d49191a7202

2004 Chevrolet... | Answered on Oct 24, 2017 | 64 views


notify chevy of your complaint this fixya we are not affiliated or associated with chevrolet or their vehicles

2004 Chevrolet... | Answered on Jul 08, 2017 | 546 views


if you have specific details as to the times , rpms , conditions that cause the problems take it to an accredited auto transmission specialist shop and have it diagnosed
with your details they should be able to pinpoint the fault as it will not be uncommon

2004 Chevrolet... | Answered on Jun 08, 2017 | 86 views


Should be in the upper line that goes into the evaporator

2004 Chevrolet... | Answered on Aug 22, 2016 | 1,702 views


This may be related to the antitheft system The system is known for turning off the starter and/or injectors when it fails. Is there a light on the dash that says SECURITY? This is a common problem worth looking into. http://www.diy-gm-security.com/

26024633-vycpj41x2iphfdmbx4v0vfed-3-2.jpg

2004 Chevrolet... | Answered on Dec 30, 2015 | 144 views


either dead battery or a bad starter .

2004 Chevrolet... | Answered on Dec 27, 2015 | 115 views


Check your shop manual.

2004 Chevrolet... | Answered on Oct 02, 2015 | 74 views


The actuator is probably way up under the dash and impossible to see until you remove AC pipes or glove box. Check shop manual if possible.

2004 Chevrolet... | Answered on Mar 25, 2017 | 5,708 views



The HR arrow is the left one and the MIN arrow is on the right.

Here's the instructions from the manual:

Press and hold the HR or MIN arrow for two seconds.
Then press HR until the correct hour appears on
the display. Press and hold MIN until the correct minute
appears on the display. The time may be set with the
ignition on or off.
Hold either arrow down for two seconds and then you can adjust the hour and minutes.


2004 Chevrolet... | Answered on May 04, 2015 | 283 views


because ignition key has a chip that allow ecm to start the engine if you are using a key copy it will not working, if you don't have the original key with the chip on it you must take vehicle to the dealer to disable the security program on engine computer

2004 Chevrolet... | Answered on Apr 23, 2015 | 268 views


50 thousand miles

2004 Chevrolet... | Answered on Apr 23, 2015 | 38 views


see attached - I assumed you have ac 21887722-b2l3qrdyfwartoeunww2aiqc-4-0.gif

2004 Chevrolet... | Answered on Jan 04, 2015 | 905 views


Check for damaged linkage cable or the shifter it self.

2004 Chevrolet... | Answered on Nov 06, 2014 | 230 views


Turn signal doesn't have a relay. If your talking about the flasher, it is built into the hazard switch. Which yours may or may not be in the turn signal switch. If the hazard is on the column, then it is in the switch. In the dash, it's not. I haven't worked on the express, but that's where GM puts them.

2004 Chevrolet... | Answered on Aug 21, 2014 | 704 views


had the same problem. Trace pink wire in harness rubbing on dogbox frame in engine compartment.

2004 Chevrolet... | Answered on Aug 01, 2014 | 870 views


replace discpad or breakshoe

2004 Chevrolet... | Answered on Jul 13, 2014 | 32 views


replace the discpad or breakshoe

2004 Chevrolet... | Answered on Jul 13, 2014 | 22 views


80% of the belt will go around the crank pull. that makes it easy then 80%

2004 Chevrolet... | Answered on Jul 08, 2014 | 96 views


Front or rear?

2004 Chevrolet... | Answered on Jul 07, 2014 | 54 views

Not finding what you are looking for?

336 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Chevrolet Experts

Marvin
Marvin

Level 3 Expert

85216 Answers

Jonah Oneal

Level 3 Expert

14092 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...