My 1994 2.2L toyota camry radiator fans do not work. They do wrk when I hot wired them. The fuses and the radiator temp. swith has been replaced. I do have continunity between the 1&2 pins of the relays and none between the 3&5 pins. I have not applied applied voltage to the relays to test them. The machenic that replaced the radiator temperature switch says that the car needs to get above 240 degrees before the fan will work. I dont think he knows what to do. Any help is appreciated.
Hi.....
The Normal Temperature Range to the Fan Start is: A/C ON 181 F.
A/C OFF 199 F. When the Engine Reach this Temperature the Fan should start.
OK. Do this simple test.
1---- Start the engine, Desconnect the ECT Switch located on the Radiator,
See if the Fan come ON. If yes, if not go to step #2
Connect the ECT SWITCH and leave the car Running and with a Temperature gage.
See the temperature, if the Temperature go more than 199 F.
Turn the Engine OFF.
Disconnect the ECT sensor and check for Ground at the WHITE/BLACK wire.
If ground exist, Replace the ECT switch.
But if not. Check the wire for any damaged, and the ground at the Front Left Fender.
Repair as need.
2---- check the Fuse link RDI FAN . 30 amp.
Check the Fuse link CDS FAN 30 amp.
Replace if need.
And Return to step # 1.
Check the Radiator fan Relay, Rad fan relay 2 and 3. Replace if need.
Ok. I hope this help on your question.
I can give to you the WIRING DIAGRAM of the Fans, But I need a E-MAIL adress to do that.
Thank you for use fixya....
hey can i get the diagram to [email protected]
×
Mine did the same thing. Check the fan relay which is in the relay pack mounted near the LF fender in the engine room.
Buy a Haynes manual for $20, and it'll show you how to do it. I'd recommend a used relay. A new one will set'cha back about $&0
Keep the car. I got into a newer one and they're HALF the cars those older ones are
4,130 views
Usually answered in minutes!
I HAVE THE SAME PROBLEM TOO. CAN YOU PLEASE SEND ME A DIAGRAM TO MY E-MAIL ADDRESS. ITS [email protected]. My dad has been tryig to fix my car forever.
I have same problem and car...
my two fans do not turn on. When I turn on my ac, the a/c clutch does not engage either. I moved from California and now live in Illinois where the weather is -6 degrees. would that temp freeze up the cluthc also?
The radiator fan 1 and sender unit
×