SOURCE: 2002 Civic Dx Clutch?
i have just replaced an 03 civic ex clutch and transmission bearings due to a customer being too harsh on it. It sounds like its got a little life left in it if you are easy on it.
if there is adjustment in this model use the below walkthrough to adjust it.
adjust the clutch pedal,
1. if you look up on the top of the clutch pedal, the first thing you should see if a clutch pedal position switch, and right behind it there is a locknut, looens the locknut. once you loosen it, back off on the pedal position switch or adjusting bolt untill it no longer touches the clutch pedal.
2. now behind the clutch pedal, there is a pushrod. and on that pushrod, there is a locknut, loosen that locknut. Now turn the pushrod in or out to get the desired height and stroke at the clutch pedal.
The freeplay is the amount of push on the clutch pedal to where is starts to have resistance from the top. I have usually been told it should be set at 1 1/2-2 inches of freeplay.
Once you set it, tighten the locknut on the pushrod. With the clutch pedal released, turn in the clutch pedal position switch untill it contacts the clutch pedal. then turn it an additional 3/4 to 1 turn. And tighten the locknut.
Now on top of the clutch pedal switch, there is a clutch interlock switch. Loosen the locknut on that switch. then press the clutch pedal to the floor.
release the clutch pedal 15-20 mm (0.59-0.79 in) from the fully pressed position, and hold it there. adjust the position of the clutch interlock switch so the engine will start with the clutch pedal in this position. then tighten the locknut on that switch.
Hope this helps
SOURCE: Need to know how to bleed clutch of 1995 honda
Fill the clutch reservoir with new brake fluid and kneel down beside the car, reach in with your hand and pump the clutch pedal up and down until it starts to return on it's own. Check the reservoir level, hop in the car and pump the pedal about twenty times with you foot, the clutch will self bleed and you'll be able to shift. If there is a leak somewhere, this problem will reoccur until the cause of the leak is fixed.
SOURCE: daigram of 1995 Honda Civic EX plug clutch pedal ?
95 civic coupe ex brake lights wont work and the shifter locks in park position, what's wrong?
SOURCE: Honda civic vti 1994 clutch pedal adjustment
you mite have 2 change your pressure plate. unless its ran by fluid.
SOURCE: 99 civic clutch hangs
you may still have an air pocket in the line try bleeding it a little more
255 views
Usually answered in minutes!
×