Question about 2002 Ford F250 Super Duty SuperCab

1 Answer

2002 Ford F250 Diesel Glow plug control - 2002 Ford F250 Super Duty SuperCab

Posted by Anonymous on

Ad

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    MVP:

    An expert that got 5 achievements.

    New Friend:

    An expert that has 1 follower.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Contributor
  • 26 Answers
Ad

6 Suggested Answers

6ya6ya

6ya staff

  • 2 Answers

SOURCE:

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Ad
fastboyz

paul erickson

  • 674 Answers

SOURCE: 1995 ford 7.3 litre diesel glow plugs

the best way i have found to test glow plugs is to disconnect the wire to the plug and get you 12volt test light and put your negitive lead of the test light on the positive battery cable so when you touch the test light to any ground the light will light. so now go check your glow plugs and if you have one that doesnt light the light its burned out.
good luck

Posted on Oct 27, 2008

Anonymous

  • 24 Answers

SOURCE: 87 Ford F250 turns over but wont start

Fuel cut off switch or inertia swith on passenger side kicker panel, it might have got accidently kicked while getting out.

Posted on Feb 21, 2009

Roger Foster

  • 701 Answers

SOURCE: f250 Diesel will not start cold . Has power to

Hello philkatkiele: My name is Roger and I will help you. First thing you need to check is the glow plugs. They will need tested individually. Un plug all 8 glow plugs. Take a test light and hook end to the positive battery cable. Touch opposite end of test light to the terminal end of the glow plug. The test light should light. Touch all 8 glow plugs. Ant that do not light are bad and will need replaced. If glow plugs are burnt out then the controller will flash wait light to early or very fast. The wait light should be on for approximately 10 seconds.If al glow plugs check ok then I would suspect the glow plug controller as the problem. Also if the temperature out side is below 40 degrees the truck should be plugged in. This will help to make the engine start easier. Should you need further help please just ask.Please rate the answer as this way I know it was helpful. Thank You for using Fix Ya. Roger

Posted on Feb 15, 2010

Testimonial: "Thank you, Glow plugs are new. It helps to have a second oppinion"

tvsracer17

  • 1 Answer

SOURCE: 2005 ford f250 FX4 6.0L diesel. Hard to start all

2005 F250 6.0L hard to start

Posted on Oct 20, 2010

tripletauto

TripleTauto

  • 1450 Answers

SOURCE: Need the glow plug/controller wiring

HERE IS THE DIAGRAMtripletauto.gif

Posted on Dec 15, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Ford F250 2002 7.3 Diesel won't start


check engine immobiliser and crank position sensor . Run fault codes and replace faulty units.

Apr 04, 2013 | Ford Cars & Trucks

1 Answer

Replaced glow plug module because there was a burn't wire, still have the problem but no codes coming up


better check the vehicle first. and if not start ,check fuel line. must have a solid fuel line.

Oct 27, 2012 | 2002 Ford F250 Super Duty SuperCab

2 Answers

We think it is the diesel injection pump but not sure


Sounds like not all the glow plugs are working.It should run fairly smooth on a cold start if all of the glow plugs are working..Also you shouldn't drive off on a cold start with a diesel,Its really hard on the motors..At least give them 10 to 15 min on a cold start..The oil in them is a really thick oil and when there drove on a cold start theres no oil lubricating the internal parts and will cause the motor to seize up..You may already no this and dont mean you drive it as soon as you start it i just wanted to let you know..When you get alot of white smoke it could be two things,Theres water in the fuel which will make it not have much power die and smoke..But if it runs fine when its warm theres some bad glow plugs...Hope this helps you and have a great day

I’m happy to assist further over the phone at https://www.6ya.com/expert/joe_a3369546f8067589

Dec 08, 2009 | 2002 Ford F250 Super Duty SuperCab

1 Answer

Ford 2002 f250 7.3 diesel won't start on cold mornings just replaced the cold start relay and still won't start...what else could it be?


It probably is your glow plugs which are controlled by the cold start relay. They burn out over time. This is normal. Haynes Diesel Engine Repair Manual, part 10330, will walk you through the diagnosis and replacement easily. It's about $20. Hope this helps.

Oct 05, 2009 | 2002 Ford F250 Super Duty SuperCab

1 Answer

1993 ford f250 7.3 diesel glow plugs not working. what to do?


Check the fuse first then check the wire harness and connection working your way back from the glow plug to the fuse box. Good luck and hope this helps. If everything is good then replace the glow plugs. 

Jul 03, 2009 | 1993 Ford F250

2 Answers

7.3 l diesel wont start


Bad glow plugs and/or glow plug controller. Common issue with these vehciles. Some also have harness failures. Replace all glow plugs as a set not individually.

Mar 29, 2009 | 1991 Ford F250

Not finding what you are looking for?
2002 Ford F250 Super Duty SuperCab Logo

517 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts

Marvin
Marvin

Level 3 Expert

85222 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

gerry bissi

Level 3 Expert

4388 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...