SOURCE: Need location of oxygen sensor on 2002 dodge caravan sport
o2 sensors are located in the exhaust pipe near the front of the system (sometimes in the exhaust manifold)........your van may have more than 1 so check with the dealer (free phone call) to see if your system has multiples........as for tools all you should need is the proper size wrench (note: to remove the old one you can cut the wire off and use a socket) the pipes are subjected to extreme temperatures and the old one may be difficult to remove.
hope this helps!
SOURCE: how to replace 1998 dodge ram van water pump
There is a special spanner wrench that you need to hold onto the water pump pulley (the 2 holes in the big pulley the belt rides on).
The tool has a Y shape to it with a handle coming off the bottom end of the Y. There will be 2 pins in the ends of the V that fit into the holes on the pulley (adjustable). You put the pins into the holes, grab the handle with the left hand, and put a 15 inch cresent wrench in the right hand onto the clutch nut. Pull up on the Y shaped tool handle with the pins, push down on the wrench to the left (counter clockwise) to un-screw the clutch from the pulley.
Then take the clutch off the fan after you have it out of the truck.
LEAVE THE BELT ON UNTIL YOU GET THE PULLEY LOOSE!!!
THEN, take the belt off, then the pulley/clutch asembly off, then the water pump (replace with a NEW - NOT REBUILT PUMP).
The new only costs 20 bucks or so more, and it is worth the headache of paying more while you have it apart. If the clutch is shot, the pump is close behind because of the vibrations ruins the seals/bearings on the pump, even though you cant hear the noise, it is there. Take the LOWER fan shroud completely off by removing the trans lines from the radiator. pull the fan out the BOTTOM of the Van. Leave the top shroud in place but take the screws out so you can manuever the lower shroud out. You also may have to remove the lower radiator hose and move it aside. Good time to change coolant anyway. And since you are in there on top, change the thermostat, while you are doing the cooling system service. Use a PREAMIUM BRAND thermostat, like a STANT, it will have a small vent hole with a valve in it hanging off the side edge of the thermostat that helps vent air from the system so it will not overheat. Trapped air can cause the cooling system to overheat, so dont put the thermostat in upside down! Point go's UP.
GOOD LUCK.
SOURCE: remove the rear brake drum on 2004 Dodge Caraven
No just make sure your emergency cable is off and take a large hammer an hit it around the edge or corner lightly and spin at the same time also try pulling with your other hand as you spin this is a technique all mechanics use its very unlikely that you will have to loosen up the shoes with a brake spoon.REMEMBER THE OUTER ROUNDED EDGE ONLY WHERE ITS THE THICKIST.
SOURCE: 92 dodge caravan timing belt diagrams???
I have changed many of them.Any auto parts store should have this info!Also sometimes it comes with a new belt!
SOURCE: Heat troubles..92 dodge caravan 3.3L..new
If it is fogging your windows, you have a leaking heater core. Dash removal is required to fix it.
Testimonial: "great advice,,but I am not losing antifreeze from my cooling system,"
125 views
Usually answered in minutes!
×