Procedure to replace
Drain coolant until below water pump level. loosen water pump pulley bolts.then remove drive belt by rotating belt tensioner.remove drive belt from the right of idler pulley.carefully release the drive belt tensioner spring tension.then remove water pump pulley bolts and pulley.remove water pump bolts and water pump pay attention to the position old water pump when removing water pump so you can line up new water pump holes to the engine. be sure clean engine water pump mounting surface use gasket remover dont scratch engine surface when cleaning removing old gasket material. take new water pump gasket get it mounting holes line up with new water pump mounting holes.when done getting engine water pump surface clean.water pump gasket paper you need to put thin layer of sealer on both sides of water pump gasket use RTV SILICONE.LET SET UP 10 MINUTES. PUT GASKET ON WATER PUMP BUT FIRST MAKE SURE LINE UP GASKET HOLES WITH WATER PUMP HOLES BEFORE PUTTING ON THE GASKET SEALER.when gasket sealer set up 10 minutes then install new water pump with gasket to the engine torque to 89 inch lbs.or 10 NM that is about 7 ft lbs torque.you should be able turn water pump by hand if you cant turn water pump by hand got too tight damage water pump shaft bearing.when all done wait for THREE HOURS. before adding coolant i let RTV CURE SOME. torque water pump pulley bolts 18 ft lbs.
Benefits of Goulds Pumps
The quality of the Goulds brand, which is respected and known internationally and is offered in more than 150 countries, speaks for itself. Although Goulds is renowned for its high calibre products, its wide range of offerings is truly astounding.
Since Goulds pumps have been available for many years, you may be sure that their quality has endured. Additionally, you may be confident that they have kept up with developments in pump technology. For a good reason, Goulds is one of the greatest brands in the market, and when you purchase one of their pumps, you can be confident that you're getting a high-quality answer to your pumping demands.
Goulds Pumps has a reliable and long-lasting solution for all your pumping needs, whether you have a wet basement that needs a sump, an ancient well with an antiquated pumping system, or you're a builder with a sizable pumping project. Their pumps undergo extensive testing and must adhere to tight pressure, temperature, corrosion, and abrasion requirements. And Goulds Pumps is the only process pump manufacturer in the market equipped with digital monitoring.
https://www.pumpproducts.com/brands/goulds.html
For
complete water pump replacing procedure, step by step, there are few help
links.I suggest you to refer the help links.
-------------
Click
the link below:-----
http://technoanswers.blogspot.com/2011/11/water-pump-replacing-procedure-for-all.html
--------------
HOW TO REPLACE A WATER PUMP
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-water-pump.html
-------------
http://carbeltrouting.blogspot.com/2011/12/how-to-route-water-pump-belt-for-1992.html
-------------
http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-water-pump-on-acura-car.html
--------------
http://technoanswers.blogspot.com/2011/12/how-to-remove-water-pump-on-toyota.html
-------------
http://technoanswers.blogspot.com/2011/12/where-is-water-pump-located-on-toyota.html
------------
These
will help.
Thanks.
http://technoanswers.blogspot.com/2011/11/water-pump-replacing-procedure-for-all.html
--------------
HOW TO REPLACE A WATER PUMP
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-water-pump.html
-------------
How to route Water
Pump Belt for 1992 Oldsmobile Cutlass Ciera?
http://carbeltrouting.blogspot.com/2011/12/how-to-route-water-pump-belt-for-1992.html
-------------
How to replace Water
Pump on Acura Car models?
http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-water-pump-on-acura-car.html
--------------
How to Remove Water Pump on Toyota Previa?
http://technoanswers.blogspot.com/2011/12/how-to-remove-water-pump-on-toyota.html
-------------
Where is Water Pump located on Toyota Corolla?
http://technoanswers.blogspot.com/2011/12/where-is-water-pump-located-on-toyota.html
------------
These will help.
Thanks.
For water pump replacement i suggest you to check the help link
provided below.
click the link below :----
Water pump replacing procedure for all vehicles?
http://technoanswers.blogspot.com/2011/11/water-pump-replacing-procedure-for-all.html
---------
HOW TO REPLACE A WATER PUMP
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-water-pump.html
------------------
How to route Water Pump Belt for 1992 Oldsmobile ?
http://carbeltrouting.blogspot.com/2011/12/how-to-route-water-pump-belt-for-1992.html
---------
How to replace Water Pump on Car ?
http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-water-pump-on-acura-car.html
---------
How to Remove Water Pump?
http://technoanswers.blogspot.com/2011/12/how-to-remove-water-pump-on-toyota.html
-------
Where is Water Pump located ?
http://technoanswers.blogspot.com/2011/12/where-is-water-pump-located-on-toyota.html
-----------
This will help. Thanks
For water pump replacement i suggest you to check the help link
provided below.
click the link below :----
Water pump replacing procedure for all vehicles?
http://technoanswers.blogspot.com/2011/11/water-pump-replacing-procedure-for-all.html
---------
HOW TO REPLACE A WATER PUMP
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-water-pump.html
------------------
How to route Water Pump Belt for 1992 Oldsmobile ?
http://carbeltrouting.blogspot.com/2011/12/how-to-route-water-pump-belt-for-1992.html
---------
How to replace Water Pump on Car ?
http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-water-pump-on-acura-car.html
---------
How to Remove Water Pump?
http://technoanswers.blogspot.com/2011/12/how-to-remove-water-pump-on-toyota.html
-------
Where is Water Pump located ?
http://technoanswers.blogspot.com/2011/12/where-is-water-pump-located-on-toyota.html
-----------
This will help. Thanks.
For water pump replacement i suggest you to check the help link
provided below.
click the link below :----
Water pump replacing procedure for all vehicles?
http://technoanswers.blogspot.com/2011/11/water-pump-replacing-procedure-for-all.html
---------
HOW TO REPLACE A WATER PUMP
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-water-pump.html
------------------
How to route Water Pump Belt for 1992 Oldsmobile ?
http://carbeltrouting.blogspot.com/2011/12/how-to-route-water-pump-belt-for-1992.html
---------
How to replace Water Pump on Car ?
http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-water-pump-on-acura-car.html
---------
How to Remove Water Pump?
http://technoanswers.blogspot.com/2011/12/how-to-remove-water-pump-on-toyota.html
-------
Where is Water Pump located ?
http://technoanswers.blogspot.com/2011/12/where-is-water-pump-located-on-toyota.html
-----------
This will help. Thanks.
For water pump replacement i suggest you to check the help link
provided below.
click the link below :----
Water pump replacing procedure for all vehicles?
http://technoanswers.blogspot.com/2011/11/water-pump-replacing-procedure-for-all.html
---------
HOW TO REPLACE A WATER PUMP
http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-water-pump.html
------------------
How to route Water Pump Belt?
http://carbeltrouting.blogspot.com/2011/12/how-to-route-water-pump-belt-for-1992.html
---------
How to replace Water Pump on Car ?
http://repairhelpcenter.blogspot.com/2011/11/how-to-replace-water-pump-on-acura-car.html
---------
How to Remove Water Pump?
http://technoanswers.blogspot.com/2011/12/how-to-remove-water-pump-on-toyota.html
-------
Where is Water Pump located ?
http://technoanswers.blogspot.com/2011/12/where-is-water-pump-located-on-toyota.html
-----------
This will help. Thanks.
2,191 views
Usually answered in minutes!
×