SOURCE: fuel pump relay for a 1994 Chevy Truck WT1500
The Fuel Pump Relay is located in the Glove Box under a little cover on the upper left side. The Fuel Control Relay is the left relay and The Fuel Pump Relay is the right. To test these relays, swap them and then try to start the vehicle, or blow the horn. If the horn blows then use that relay for the pump and you may at least drive the vehicle where needed! If the vehicle starts, then replace them as a pair.
SOURCE: replace fuel pump on 1995 caprice classic
Un plug fuel pump wires at back of tank mounted on the frame at very rear of car. Remove hose clamps at back of tank going to filler tube and vent. Place a jack with a piece of would on the top of it under the center of the Gas tank. Remove the straps that criss cross the tank. Two in front and two in back. Very slowly lower the tank, there are some fuel lines going to the fuel pump that need to be removed if the tank comes down too far you could bend the pump lines. You will need fuel line tools to remove the lines from the metal lines coming from the pump. Once these are removed lower the tank the rest of the way and pull tank out. There are about five or six 10 mm nuts on the top of the pump hold down ring. Remove the nuts. Then slowly remove the pump from the tank. Be careful of the float for the fuel level you may have to lean the pump to one side as you remove it from the tank... you will only need to replace the pump not the whole module on this model..The pump is in the plastic module. Unplug the wires going to the pump then unsnap the plastic top. Remove the filter from the bottom then push the pump out. Reverse steps with new pump.
Fuel relays on this model almost never go bad. If you hear the pump its not a relay. But just because you hear the pump does not mean the pump is working right. It may be loosing pressure...
Loss of spark was also a problem the the 95 4.3 v8. and the distributor located at the front of the engine behind the damper and water pump was the problem and very expensive....
SOURCE: trying to locate fuel pump relay for 1991 corvette- coupe
The fuel pump relay in the 1991 corvette is located under the IP on the pass side.
Open pass door, unscrew two screws under the glovebox (you will be upside down in the car), take off the fuse panel, unscrew third screw to plastic plate underneath glovebox, pull away carpet (velcro), pull down plastic plate (watch out for the wiring to the lamp), then under the glovebox you will find a number of fuses and relays if you dive in under there DEEP, prob 4 or 5 in a row, not really sure wich one, but one in the middle is the fuel relay, and they are the same (interchangable).
Take a look at --the12volt.com/relays/relays.asp--
It´s those relays we are talking about.
SOURCE: Fule pump fuse and relay location on 1993 Chevy k1500
I too am looking for the fuel pump fuse. Cant locate the fuse box in the engine bay. No green or black box. If u have found where it is please let me know.
[email protected]
43 views
Usually answered in minutes!
×