SOURCE: 2004 sprinter Black smoke
is the ceck engine light on and if so what codes exist.......a bad resonator or carge air hose can cause the black smoke. where are you located
SOURCE: 1999 dodge ram 2500 5.9 cummins diesel
Check the fuel pressure at the filter. Odds are the lift pump, located below the filter, is toast. Continual cranking of the motor with a bad LP wil cause the injector pump to heat up and burn out. Replace the LP and fuel filter. Bleed the system by cracking the inlet to the injector pump and bumping the enigine over so the LP will run. Once you have fuel at the injector pump, crack injectors 1,3,and 4. Crank the motor for no more 6 or 7 seconds at a time until it turns over. Give the pump time to cool for a couple of mintues between cranks. This process is easier with two people, one to crank and the other to watch for fuel and tighten the injectors once it starts. If the injector pump is fried at this point from cranking with no fuel, the motor should idle, but will stumble all over itself when the throttle is applied.
-Brandon
check compression for each cylinder....if they are good check your transmission..
SOURCE: dodge cummins won't start, fuel reaching injector pump but no fuel coming out of injector pump.
You said you have fuel flowing from the inlet line of the injection pump? But not at the injector lines?
SOURCE: 1999 dodge ram 3500 cummings turbo diesel will not start.
Diesel engines fire on compression alone (usually 400psi).The Truck may have air trapped in the fuel system.When you perform any fuel system repair on a diesel it is going to take alot of cranking to get the air out. You can take the breather loose and shoot a VERY small amount of starter fluid in the intake and it should start. Do not use starting fluid much as it can damage the engine. Good Luck.
61 views
Usually answered in minutes!
×