SOURCE: diagram 2003 toyota rav4 serpitine belt routing
http://www.autozone.com/autozone/repairinfo/repairguide/repairGuideContent.jsp?partName=Engine+Mechanical&pageId=0900c1528019c35b&partId=0900c1528019c35b
go here i think this will help
SOURCE: 1994 toyota fuel pump relay
Fuel pump relay is in the engine compartment left side fuse block
SOURCE: how to replace a fuel pump on a toyota rav4 1998
you need to remove the rear seat to get to it, just keep in mind the system is preasurized, which in english means you need to loosen the fuel filter in the front of the car first, "THIS IS CRITICAL" if not you will cause gas to get all over the interior. The 96-00 rav4 has a hatch under the carpet, under the seats in the rear. it is a pain to get to, once you remove the seats and carpet you will see it. I would recomend you bring it to a dealer if you dont know what you are doing. But if you are like me and figured what the hell, then you will want to take these steps first...
1. Let the car sit for a long period of time, about 3 hours or more.
2. Have a low amount of fuel, do not have a full tank
3. loosen the gas cap
4. Remove the intake, and the fuse box,
5. Loosen the top nut on the fuel filter under the hood to let out the remaining pressure, do not loose the O rings. This is a good time to replace that filter too, it is about 30 bucks from toyota.
6. open the hatch in the rear,
7. remove the electric feeds from the pump.
NOTE: YOU CAN REMOVE THE POWER FROM THE PUMP AND START THE CAR TO TAKE OUT THE PREASURE, BUT I FOUND IT BETTER TO DO IT MY WAY DUE TO WHAT IT TAKES TO START IT AFTER YOU DO THIS.
8. line the floor of the rav with Plastic, bags, or cardboard, or something.
9. remove old pump
10. install new pump
11. Re attach the fuel filter or install new filter
12. get car back together enough to start it, make sure you have all the lines connected, if not gas will get everywhere...
Good Luck, it was a FUN adventure to do this...
SOURCE: Where is located the fuel pump relay for a rav4
The relay is the ECM relay and it's in the fuse relay center under the hood near the battery. there is an EFI fuse alson and then theirs two more fuses after the relay ones fuel pump the other ECM. If the check engine light doesn't come on with the key the relay or the ECM fuse is blown if only the fuel pump does'nt work then the fuel pump fuse is blown or the fuel pump is bad.
SOURCE: 2003 navigator fule pump relay
Located under the dash on drivers side.
Testimonial: "that doesnt help me at all. need a exact location of relay"
1,323 views
Usually answered in minutes!
×