Do you know how to test automotive electrical circuit's ? Viewing wiring diagrams an using a DVOM - digital volt ohm meter ? Free wiring diagrams here . http://www.bbbind.com/free-tsb Enter vehicle info. year , make , model an engine . Under system click on body & accessories , then under subsystem click on wiper/washer . Click the search button then the blue link.
An using factory pin point diagnostic's .
PINPOINT TEST B: THE WIPERS STAY ON CONTINUOUSLY
Test Step
Result / Action to Take
B1 CHECK THE MULTIFUNCTION SWITCH
Yes
GO to B2 .
No
INSTALL a new multifunction switch. REFER to Section 211-05 .
B2 CHECK CIRCUIT 57 (BK) FOR AN OPEN
Yes
GO to B3 .
No
REPAIR the circuit. TEST the system for normal operation.
B3 CHECK CIRCUITS 56 (DB/OG), 58 (WH), 61 (YE/RD), AND 63 (RD) FOR SHORTS
Yes
Windshield Wiper Motor C125
Ground
pin 10, circuit 56 (DB/OG)
ground
pin 11, circuit 58 (WH)
ground
pin 1, circuit 61 (YE/RD)
ground
pin 9, circuit 63 (RD)
ground
GO to B4 .
No
REPAIR the circuit(s) in question. TEST the system for normal operation.
B4 CHECK FOR CORRECT WIPER MOTOR OPERATION
Yes
GO to B5 .
No
The system is operating correctly at this time. Concern may have been caused by a loose or corroded connector. TEST the system for normal operation.
B5 CHECK THE WINDSHIELD WIPER MOTOR
Yes
The system is operating correctly at this time. Concern may have been caused by binding or incorrect pivot arm adjustment. REFER to Windshield Wiper Blade and Pivot Arm Adjustment in this section. TEST the system for normal operation.
No
INSTALL a new windshield wiper motor. REFER to Windshield Wiper Motor in this section.
SOURCE: replace axle seal on 2003 lincoln town car
You have to remove the differential housing cover.
Then turn the center housing until you can see the 5/16 bolt that holds the center pin that goes thru the spider and axle gears.
Remove the bolt and center pin,be careful that the gears stay in place.
Then push in on the axles to expose the c-clips on the end of the axles and remove the c-clip.
Then remove the axle.
SOURCE: 89 Lincoln Town Car's brake lights keep coming on.
YOU HAVE A FAILTY RELAY AND SWITCH IN THE CAR
SOURCE: 2003 lincoln town car code p0705 & p1702 changed tr sensor only when car starts
03 Town Car transmission whines & taps on very hot days only, changed fluid filter, trans cooler & radiator. Runs great on cool on days under 90 degress.
SOURCE: 1996 Lincoln Town Car trunk motor won't shut off
under the trunk lip (directly where the latch goes into the lock jaws; remove the carpet so that you can see the side of the trunk latch; on the latch jaws (bottom) is a switch that contacts the latch (top) this switch is broken or, mis-aligned it opens (stops the trunk motor) when the latch contacts it.
Testimonial: "Thanks much for your speedy and knowledgeable reply."
SOURCE: 2003 Lincoln Town Car - Power window switch removal/installation
SECTION 501-05: Interior Trim and Ornamentation
2003 Town Car Workshop Manual
REMOVAL AND INSTALLATION
Procedure revision date: 01/28/2002
Front Door Trim Panel 
Printable View (206 KB)
Removal and Installation
NOTE: LH side shown, RH side similar.
CAUTION: Use care not to damage the trim panel covers.
Open the screw covers.
![2010&c18=modelyear&c20=n306887&c35=wsm%2cfront%20door%20trim%20panel%2cs3g%2c501-05%2cremoval%20and%20installation&s=1600x900&c=32&j=1.3&v=y&k=y&bw=1171&bh=582&ct=modem&hp=n&[aqe]](/uploads/images/2010&c18=modelyear&c20=n306887&c35=wsm%2cfront%20door%20trim%20panel%2cs3g%2c501-05%2cremoval%20and%20installation&s=1600x900&c=32&j=1.3&v=y&k=y&bw=1171&bh=582&ct=modem&hp=n&[aqe])
1,186 views
Usually answered in minutes!
×