SOURCE: stalling at lower speeds
sounds like idle air control valve, a 4 wire connector and two screws on throttle body.
SOURCE: 1996 Dodge Ram 1500 kept stalling while driving now won't start
First off you can test the fuel pump 2 ways
1.have a assistant turn on the ign to on while you listen for the pump to run at the gas cap (gas cap off).
2.find the valve on the fuel rail looks like a a/c or valve stem,take the cap off and press the needle and if fuel comes out then it's not the fuel pump.
But from a lot of EXPERIANCE on dodge engines the stalling and restarting issue is ignition related i.e crank or cam sensor which will throw a diagnostic code of engine misfire xxx cylinders.
So If its one of those sensors then you will not have any spark,and staring fluids will not fire the engine.
As for the headlights flickering they get there power through a relay straight from the battery,so I would look at the relays under the hood and find the one for the headlights and swap it out with the horn relay as most of the relays will have the same numbers.
The crank sensor is about 70.00 and the cam sensor is about 50.
depending on where you get them (dealer or aftermarket)
the cam sensor is the round plastic thing under the dist cap,and the crank sensor is on the pass side under the head into the top of the transmission bell housing and it's a 2hr job to change because of it's location is really hard to get to.
Hint -take the breather off and place a rag over the intake and a board from the radiator core support to the intake to lay on,it has 2 10mm bolts and the wiring harness unplugs from underneath.
SOURCE: 2001 dodge grand caravan stalls
Glad too hear your making progress, sounds like your dealing with a reasonable shop too. For future reference, take notes when your vehicle acts up. The more information you cn give your technician the easier it is to be fixed. Good luck, let me know how you make out.
R
SOURCE: Dodge Caravan Stalls, won't turn over
i have the same van (2003), same problems, the deler just replace my PCM cost me $950 van works fine untill now.
SOURCE: The fuel consumption is to low
Tune ups, clean oil & filters , tire air pressure at rated as specied on door panel. good driving habits.. have dealer ck computer settings
376 views
Usually answered in minutes!
×