Question about 2004 Chevrolet Express

1 Answer

Chevy express conversion van air conditioning keeps breaking. this is the eighth time we have had it break in 3 years, what could be causing this? We get it fixed and within a month it stops working . The air blows out but it is not cold. The last fix was to cut the line that lead to the back of the van because that was where the leak was, so the back of the van would not have air conditioning but it still worked in the front.

Posted by on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Top Expert:

    An expert who has finished #1 on the weekly Top 10 Fixya Experts Leaderboard.

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

  • Chevrolet Master
  • 22,486 Answers

Notify chevy of your complaint this fixya we are not affiliated or associated with chevrolet or their vehicles

Posted on Jul 08, 2017

Ad

6 Suggested Answers

6ya6ya

6ya staff

  • 2 Answers

SOURCE:

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Ad

Anonymous

  • 1 Answer

SOURCE: Electronic Control Module Installation 1994 G20 Chevy Van

I just had the same problem. If it is a regular van try under the driver seat in a plastic box. If it is a conversion van try in a pannel just behind driver seat on side of van wall behind a pannel that looks like a vent.

Posted on Apr 09, 2009

Anonymous

SOURCE: 1996 chevy express van audio wiring diagram

go to www.the12volt.com

Posted on Aug 31, 2008

geo marin

  • 62 Answers

SOURCE: Rear air conditioning

The rear fan fuse is located in the engine compartment on the drivers side to the bottom right of the master cylinder there is a black cover, its right in there it should be a 30 amp fuse, if you flip the fuse cover it will tell you where it is. hope it helps, but if it blown look into the fan or the switch, it blew because of a reason.

Posted on Mar 22, 2009

Anonymous

  • 10 Answers

SOURCE: Wiring/electrical schematic info for a 2000 chevy express van

Check www.autozone.com.

Posted on Jun 14, 2009

B_o_B_1

  • 270 Answers

SOURCE: 1996 Chevy Tahoe air conditioning not blowing cold air

That "thing" is part of the compressor clutch. When it’s spinning the clutch is engaged, when it stops the compressor is off. If it’s constantly cycling, you probably don’t have enough freon in the system. But remember, however the gas escaped before, it will escape again, unless you fix the leak.

Posted on Jul 15, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

94 chevy Silverado blower moter runs but no air flow or very little


I had a 2000 safari van the 2 time I had this problem it was due to the vacuum hose break. The vacuum hoses on my van melted holes in them by laying on hot part of the engine. You could have breaks or loose connection.
https://www.youtube.com/watch?v=wcZNtRsD4jI
https://www.youtube.com/watch?v=YtyaHO-oAco

Aug 13, 2017 | Cars & Trucks

1 Answer

What would cause the change engine oil light to malfunction and not reset on a 2003 Chevy express van 1500 if procedure has been done correctly?


with the key on/engine off floor the gas pedal 3 times the hold it down till the change oil light start blinking and go away,some times it take more than 10 sec,if it didn't work try it again,some times you have to try few times,to get it done

Aug 07, 2014 | 2003 Chevrolet Express

1 Answer

Left my keys inside my van chevy express


Call a locksmith, if you try to break in you will most likely do more damage than good and end up costing more than getting a pro to open it for you. This advice comes from 45 years of work experiences.

Jan 17, 2012 | Chevrolet Express Cars & Trucks

1 Answer

Hi my 2005 chevy express van shuts off after the temp gauge jumps up and down. its not over heating. its just the gauge is malfunctioning and shutting off the engine. how can i fix it.


I doubt it is the gauge. The most likely problem is the Temp sensor sending faulty signals tot eh ECU which is causing your gauge to jump and it activates your engine safety shutoff to stop engine fires and such. Check the wires for breaks and shorts and replace the temp sensor.

Dec 29, 2010 | 2005 Chevrolet Express

1 Answer

How do you change spark plug leads on a 2006 chevy express van they seem to be stuck


Just twist them before pulling. If you break any wires, replace the whole set, when putting on wires, put some silicone grease in the boots.

Nov 04, 2009 | 2006 Chevrolet Express

1 Answer

Air conditioning belt keeps


check out the belt tension to see if that is good cause they can cause the belt to keep breaking because the spring inside goes bad.

Apr 27, 2009 | 2000 Dodge Caravan

3 Answers

1999 Chevy Express Van Side Door will not open


You need to replace the handle itself. The inside of the handle where the metal cable fitting attaches causes too much strain on the plastic and the molded groove breaks. Ford has the same problem. I don't know why these car man. dont just go back to all metal exterior handles. If you have time you can probably fix it with epoxy and washers, but the fastest way is to get one aftermarket or from a junkyard. Hope this answers your question.
Please remember to rate this fix.

Feb 14, 2009 | 1999 Chevrolet Express

1 Answer

Rear air conditioning


The rear fan fuse is located in the engine compartment on the drivers side to the bottom right of the master cylinder there is a black cover, its right in there it should be a 30 amp fuse, if you flip the fuse cover it will tell you where it is. hope it helps, but if it blown look into the fan or the switch, it blew because of a reason.

Jun 11, 2008 | 1996 Chevrolet Express

Not finding what you are looking for?
2004 Chevrolet Express Logo

Related Topics:

551 people viewed this question

Ask a Question

Usually answered in minutes!

Top Chevrolet Experts

Marvin
Marvin

Level 3 Expert

85223 Answers

Jonah Oneal

Level 3 Expert

14092 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22485 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...