20 Most Recent
2003 Harley Davidson FLHTCUI Electra Glide Ultra Classic - Page 9 Questions & Answers
How to replace right hand throttle grip 2003 ultra
Remove the switch housing screws and spread it away. Loosen the adjuster locknuts on the throttle cables and adjust cables in, this will allow you to lift the cable off of the throttle grip. Be care full not to lose the barrels.( the small round caps on the end of the cable.) Assembly is the reverse. Make sure to check proper operation of the throttle before starting the bike.
I just install new VH slip on mufflers and now the
Not expert with newer hogs but the pipes should come with reset data for your computer so you can dial in the recommended fuel/air mixture to mqatch the new exhaust pressure.It might even need new heat range combo's in plugs.Get manufacturer's spec and programer.Good luck.
My cd will not come out radio
You do not say wether it is a harley radio/harman kardon... If it is .mine went out and the stereo had to be replaced. Harley shop said there is an upgrade but you need the cd player to install it
How to remove front tire on 2003 harley flhtcui
To remove the front tire, you'll need something to lift the bike with like a frame jack. Position the jack under the bike and lift it slighty but not completely off the ground. Make sure the bike is stable and will not fall.
Lift the bike until the weight is off the front wheel but the wheel is not off of the ground. Loosen and remove the axle nut and loosen the two bolts on the bottom of the fork slider on one side. Slide the axle out of the wheel.
Now, carefully continue to lift the bike until you can get the wheel out from under the front fender. Make sure that you mark or can remember where any spacers go and in what direction they face on the axle.
My 2003 harley ultra classic has cruise control
On your throttle cables on the left side of the bike at front of the bike just ahead of the gas tank you will see a "bulge" where the connector is for cable position/sensor plugs in. check this connection first, clean it, etc. plug things back in and test it.
Please post and let us know if this helps.
JP
Change exshust
SOUNDS LIKE THIS PIPE GOT REALLY HOT, COULD BE RUNNING LEAN, CHECK PLUGS TO DETERMINE THAT.
The voltage meter bounces from 15 to 11 or 12 then
First check the grounds for all the wires, if you look under the seat you will see a number attached to the frame..well a ground bar. Then check and make sure all your connectors are tight. If you still are having the problem you will have to move the wires one at a time at several places to ascertain which one is the issue. There is no magic for locating a short unfortunately. sorry, hope this helps.
JP
How do i adjust the drive belt on the 03 ultra
Loosin the rear axel bolt and turn the adjustment screw in on both side the same amount on both side's. Then tighten the axel nut back down to what the spec foot pounds that the manuel calls for.
2003 ultra electrical problems
TRIAL & EROOR PROCESS!
try checking all earth connections!
add some extra temporary ones
[1 at a time]
just to see if a certain one solves the drama & if so then replace that item
Cheers Rob
Negative Post on the battery is Hot to the touch.
You just sound like you have a bad connection on the battery terminal .You can take it from me as a qualified electrician, that a cable or connection will get the the hottest at the source of the problem.
If your battery has a bad internal connection at the terminal post or just a bad connection to the cable, it will do this.Clean up the terminal ,fit a new lug if nessessary and if that don't work change the battery and you will be fine.
Please leave fair comment if I have helped you.
Thank you
How to change a shifter shaft on a 03 H-D dresser
you need to pull the inner primary case. Its a pain in the *** if u dont have the expertise and the tools. u can email me at
[email protected] i will walk u through it. LOT OF WORK for 4.50 part prro enginering on harleys part to have to go through this to replace it. Have done 3 in last month.
Not finding what you are looking for?