20 Most Recent 2002 kawasaki KDX 125 Questions & Answers


Hi, Anonymous for this scenario you will need your service manual that has all fastener torque specs and a wiring diagram on the back pages, parts fiche, and owners manual if you can't find the best tool you ever bought for your Kawasaki, despair not, for a mere $15 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
KDXRIDER NET View topic Best Transmission Oil to use in KDX200
KDX 200 Uses regular gas without 2 stroke oil draws oil from gearbox
1990 1991 Kawasaki KDX125 KDX250 2 Stroke Motorcycle PDF Download Manuals... $15
OEM Parts for Kawasaki
2002 Kawasaki KX125 Owner Manual

2002 kawasaki... | Answered on Sep 18, 2018


I DON'T KNOW WHAT A PLOT IS? BUT SOUNDS LIKE YOUR CDI..THE ONLY ELECTRICAL DEVICE THAT CAN NOT BE CHECKED WITH A METER..SO IF EVERYTHING ELSE CHECKS GOOD ITS THE CDI..HAVE A NICE DAY..

2002 kawasaki... | Answered on Feb 22, 2015


EITHER CRACKED HEAD.BAD HEAD GASKET..POSSIBLY BAD WATER PUMP GASKET..TO NAME A FEW THINGS TO LOOK FOR..

2002 kawasaki... | Answered on Feb 22, 2015


THIS QUESTION DONT MAKE SENSE SINCE THREES ONLY ONE SPARK PLUG ON A KDX 125..BUT A WEAK SPARK COULD MEAN ANYTHING IN THE ELECTRICAL SYSTEM..CDI,STATER,WIRING LOOM,CORRODED CONNECTION SOMEWHERE...ITS HARD TO SAY WITHOUT SEEING IT..AND SYSTEMATICALLY TESTING ITS COMPONENTS..

2002 kawasaki... | Answered on Feb 22, 2015


your clutch is draging adjust the clutch cable so that when you are on the bike with the bike off and in gear and clutch pulled in you can move the bike freely that means the clutch is engaged

2002 kawasaki... | Answered on Jan 20, 2013


Have you checked the engine earth from the starter motor?

2002 kawasaki... | Answered on Nov 12, 2012


you should be able to find used jug and just replace it along with new piston fitted to new jug or {cylinder}

2002 kawasaki... | Answered on Jan 03, 2010


Yup, needle valve. Even a spec of sand can cause this. Take it apart and clean or replace it. Get a new overflow hose on it as well (helps keep dirt out of the carb and directs excess fuel away from the hot engine).

2002 kawasaki... | Answered on Apr 30, 2009


Hi, Heartjunior and the usual suspects are:
1. Fouled spark plugs.
2. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a preliminary reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
3. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
4. Open-short-ground in the wiring between the alternator to the ignition module/CDI box to the ignition coil.
5. Faulty pins or sockets in the plug connectors.
6. Spark plug cables in bad condition, shorting/leaking, spark plug cable connections loose check for spark leakage in the dark.
7. Faulty ignition coil or electronic control module/CDI box.
8. Faulty pulse coil.
9. Faulty CKP, CMP, or BAS sensor.
10. Faulty ignition switch.
11. Faulty run/off switch
12. Tilt sensor needs a reset.
13. Security alarm failing to disarm needs reset
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
1997 kdx200 no spark
kx125 Project Part one diagnosing no spark
KAWASAKI KDX125 KDX250 2 STROKE FULL SERVICE REPAIR MANUAL 1990 1991... $15
OEM Parts for Kawasaki
1992 Kawasaki KX125 Owner Manual

kawasaki KDX 125... | Answered on Sep 16, 2018


Sophie, you should always double check with your local Kawasaki Dealers parts department but all the numbers seem to match. Good luck.

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

kawasaki KDX 125... | Answered on Apr 26, 2018


Hi, Sophie almost everything on a KX will fit a KDX

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

kawasaki KDX 125... | Answered on Apr 26, 2018


Hi, Sophie "ABSOLUTELY" parts swapping is common with most motorcycles when it comes to interchangeable or compatible parts from one model with another "EXCEPT" for the CDI's they are year-make-model "SPECIFIC" the best thing to do is call your local Dealership Parts Department or a reputable independent shop. If your location is not near a shop then go online and find a parts catalog or "FICHE" and match part numbers depending on your criteria.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Kawasaki KX125 Service Manual
OEM Parts for Kawasaki
http://mybikemanuals.com/kawasaki/kawasaki-kx-owners-manuals
Kawasaki KDX 125 A1 B1 90 92
https://en.wikipedia.org/wiki/Kawasaki_KDX125

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/gregg_c0ec1df182c7330e

kawasaki KDX 125... | Answered on Apr 26, 2018


I used to ride enduro in the 1980s on a KLX 250 :>)

Sounds like you have two issues.

Your spluttering and jolting sounds like a defective Reed Valve, but could also be carburetor float level problems. If it is runs fine when on the power band, then the carb is fine. For the cost, I would replace the reed valve.

http://www.athenaparts.com/eng/sections/view/128/carbon-fiber-reeds-for-intake-reed-valve/page:6

Regarding the electrics, this could be a few things. Check all the earthing points, especially the one on the negative side of the battery. Take the wire off where it grounds to the frame, clean and apply Vaseline which stops corrosion and is electrically conductive. Check all the connectors that you can find. Pull them and make sure they are clean and sealed. Vaseline is good on these too. The specs below confirms it is rectified and regulated. Check the output voltage of the alternator with a test meter. Check the battery is as spec Battery 12v 3Ah and get it stress tested, or just replace it, if it older than 3 or 4 years.

You really need a good workshop manual. I had them for all my scooters and bikes.

Manual
http://www.servicerepairmanualonline.com/859/kawasaki-kdx125-kdx-125sr-125-manual/

Spare Parts List
http://www.cmsnl.com/kawasaki-kdx125-a3-kdx125sr-1992-europe-nr_model11759/partslist/

Specs
http://www.motorbikespecs.net/index.dyn?flag=2&model_id=1914354&make=Kawasaki

Voltage Main Fuse 20A
Ignition CDI electronic advance
Charging System 3 phase AC, 27V@4000rpm. Rectified 14.5@4000rpm
Spark Plugs NGK BR8ES
Bulb-Headlight Battery 12v 3Ah
Ignition Timing 10.5BTDC@1300rpm - 26.5BTDC@3000rpm

Engine Type Liquid Cooled 2 Stroke Reed Valve Straight Single Bore x Stroke 56 x 50.6 mm Compression Ratio
Displacement 124mL
Lubrication System Oil injection
Starting kickstart
Carburation Keihin/PE28
Carburation Main Jet 115
Carburation Idle Jet 48
Pilot Screw Setting 1.5
Red line RPM 10,500rpm


kawasaki KDX 125 Google Search

kawasaki KDX 125... | Answered on Apr 02, 2017


KICK HARDER TRY PULL STARTING IT..IN SECOND GEAR..DOES IT HAVE ENOUGH COMPRESSION TO START?IT SHOULD START PULLING IT...START OFF WITH NO THROTTLE THAN IF NOT STARTING CRACK THE THROTTLE SO LIGHTLY AND SHE SHOULD FIRE OFF WHILE IN GEAR BEING PULLED OF COURSE BE CARE FUL NOT TO RUN INTO. WHO EVERS PULLING YOU..USE A LONG TOW ROPE..IF YOUR NOT A SEASONDED RIDER AND KNOW YOUR BIKE VERY WELL I WOULD NOT ATTEMPT THE PULL START...IF NOT CHECK YOUR COMPRESSION AND TIMING..MAJOR VACUUM LEAK MAYBE AT BASE GASKET..IS ENGINE SUCKING TO MUCH AIR? GOOD LUCK..

kawasaki KDX 125... | Answered on Jul 04, 2015


IF YOU DONT HAVE A MANUEL GET ONE..BETTER YET FIND AS MUCH INFO AS YOU CAN BEFOR ATTEMPTING YOURSELF..IF ITS NOT CORRECT ENGINE FAILURE WILL RESULT..GOOD LUCK..

kawasaki KDX 125... | Answered on Feb 22, 2015


HAYNES MANUAL..OR DEALER INFO..

kawasaki KDX 125... | Answered on Feb 22, 2015


DEPENDING ON WHICH SCREW WAS TURNED MAKES A DIFFERENCE..BUT RULE OF THUMB IS ALL THE WAY IN NOT TO TIGHT JUST FINGER TIGHT..YOU SEE THOSE NEEDLES HAVE A VERY FINE POINT ON THE END AND IF THEY GET TIGHTENED TO HARD THE POINT GET FLATTENED OUT AND DESTROYED..SO IN FINGER TIGHT AND OUT 1 COMPLETE ROTATION AND A 1/4 TO 3/4 OUT.BOTH SET SCREWS THIS SHOULD GET THE ENGINE RUNNING GOOD ENOUGH TO TUNE..PS..IF YOUR ENGINE DOSE NT AT LEAST ACT LIKE IT WANTS TO START ONLY TRY THREE OR FOUR TIMES IF NOT RUNNING ADJUST AGAIN BUT LITTLE INCREMENTS AT A TIME..NO THROTTLE NO CHOKE..DONT WANT TO FLOOD IT BEFORE IT STARTS..WHEN FLOODED IT WILL NOT START AT ALL..THE BEST WAY TO TUNE A CARB IS WITH A FLOW METER..

kawasaki KDX 125... | Answered on Feb 22, 2015


PAY ATTENTION TO WHERE THE THROTTLE POSITION IS AT WHEN THIS OCCURS .IF IT IN THE SAME POSITION EVERY TIME..YOU NEED A CARB SERVICE..IF ITS SP ERRATIC OCCURRENCE TRY USING A HIGHER OCTANE FUEL.OR CHECKING YOUR PLUG GAP.AIR FILTER CLEAN..ANY VACUUM LEAKS..ITS HARD TO ANSWER WITHOUT SEEING AND HEARING IT.. PROBABLY JUST NEEDS A TUNE UP..

kawasaki KDX 125... | Answered on Feb 22, 2015


Black dry deposits are indicitive of a very rich mixture. On your two stroke, rich is a asset but you can go too rich. It sounds like for some reason you're getting too much fuel.

I think I ran into something like this before on a Kawasaki 80. Check the screws that holds the choke plate inside the carb. They will come loose and allow the choke to close on you while riding the bike. If the screw comes out, it will go into the engine and cause serious damage. If the screws are loose, them out one at a time and put a drop of Loctite 271 (red) on them and reinstall them.

Check the float and the needle and seat to make sure that you don't have any trash in the needle and seat. Also check your tank vent. If the tank builds up vacuum, you could be running out of fuel. Sounds funny that you can be running rich but run out of fuel. The problem is that you run out of fuel so quickly that the carbon from the rich mixture doesn't have time to burn off.

Good Luck
Steve

kawasaki KDX 125... | Answered on May 09, 2013


Sorry, Depends on which model you have. Repost with model, and year. Thank you.

kawasaki KDX 125... | Answered on Aug 20, 2011

Not finding what you are looking for?
2002 kawasaki KDX 125 Logo

8 questions posted

Ask a Question

Usually answered in minutes!

Top kawasaki Experts

Arnie Burke
Arnie Burke

Level 3 Expert

6151 Answers

Marvin
Marvin

Level 3 Expert

85223 Answers

ROB

Level 3 Expert

858 Answers

Are you a kawasaki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

KDX 125 kawasaki

  • KDX 125 kawasaki

Most Popular Question

kick starting petrol leak

  • Motorcycles
Loading...