2006 kawasaki ZX-6R - Answered Questions & Fixed issues

get one of these,, don't depend on anything/one else.. Search https://haynes.com/en-us/kawasaki-ninja-zx-6r-zx-6rr-03-06-haynes-repair-manual

sounds like a low battery if it is charged the it is dirty connections check from the starter to solenoid to the battery and check the ground wire at battery and where it connects to the motor

did u check the wires from the ignition?..if the wires are ok then i think u must change the ignition contact if you need more help i had found a good service manual for zx-6r from 2006 it will help you with the electrical system and other stuff check the below link:http://goo.gl/wm4xOThanks

you need to have the stater checked and see how much volts it is putting out under normal engine rpm as well as accelerated rpm, it may be time to replace your stater/alternator!

The Kawasaki has a main fuse, located in the starter relay. Follow the red battery cable from the battery to a small plastic box. This box should have two large wires and a plastic cap, Under this cap is the main fuse. Pull that and see if it is blown and replace it if she is.

FI stands for Fuel Injection. The fuel system sensors have detected a problem. It could be anything > a dirty air filter restricting airflow, a plugged injector, an error in fuel mapping, any number of things. Serious problems can trigger the computer to prevent the engine from starting until the problem is fixed. You will need to take the bike to a dealer to have them plug in a code reader. The code reader will tell you exactly what problem has been detected. There is also a chance a sensor has gone bad and is giving a false signal. Keep that in mind. Now determine if you want to do the fix or have the dealer do it.

sounds like someone has fitted an alarm or anti theft kill switch at some stage. If theres no wires to it , forget about it or remove it

Hope this will help

http://www.colorrite.com/matrix-colors.cfm?CFID=3893207&CFTOKEN=27409477

The only difference between the mph and kph is the speed "O" face. I buy bikes in the US and use them in Canada "metric" most Honda's you can just change out the Speedo. Kawasaki if you can take the speed "O" apart to get at the face then you should be able to just by the face and install it.

Another way and I've done this many times is to get red dot stickers and put at specific speed like 60 and 70 kph for in town 80 and 90 for secondary roads and 100 for HWY. What I'm doing right now with my Honda Magna is turning on my bike GPS which I mounted over the Speedometer that thing is dead nuts accurate. Lots of ways around it

It could be as simple as the fuel light. When the bike is in that position, depending on how much gas was in it, you would be shifting all the gas to the back of the tank, and possibly off the gas sensor.

hiya

i found an online manual for this bike if that helps?

you can find it here

http://www.sirbrockman.com/

TheRoot42 Click Directories
images Game Zx-6r 2005/2006 manuals
PDF files Assembly Parts Service Complete Zip Rar
just go to the site and click zip under complete


hope this helps


John

It sounds like you have an air lock in the system .
I would make sure to use the right brake fluid , drain the system and bleed the brakes again and making sure that no air is locked in the system

IF ITS LIKE THE ER-5. YOU HAS TO TAKE THE CARBS OF AND REMOVE THE RESTRICTORPLATE IN THE INTAKE . SOME HAD DIFFRENT THROTTEL CAPS INSTEAD

I had mine do that...it was the battery.

IF YOU CANT TURN THE ENGINE A HOLE TURN IT HAS AN INTERNAL DAMAGE -LIKA A BROKE ROD -BROKEN TIMING CHAIN , IF YOU UNLUCKY THE ENGINE IS TO FAR GONE SOO IT WILL BE CHEAPER TO GET ANOTHER INSTEAD , SEE THIS AT MY SHOP TIME TO TIME ,

the engine # should be on a sticker on the forks.

take teh side fairing off, then youll see the screws for the seat take those out and slide the seat towards the front of the bike and it should slide out

You have to remove the rear seat first (with key) and then you'll see the lock for the front seat

there should be a key hole under the left side of the back fairing, put the key in a turn in and pull the back seat off.

depending on your modle of course is it?

ZX636C6F Ninja ZX-6R (2006)
or
ZX636D6F Ninja ZX-6R (2006)

be carefull toc hose properly./ take your time and you will be happy with your order.

Go To The Site

this is what i found for you.