20 Most Recent
1993 Suzuki VS 800 Intruder Questions & Answers
93 suzukie intruder dies after driving for a few
Ensure your choke cable is retracting properly. I had that on an old Honda and tried everything till I spotted the cable getting trapped under the tank. Look at the top of the carbs and wiggle the choke. If its sticking use something like Castrol LM grease or Coppa Slip as these last longer than WD40 releasing oil.
Owners manual
Charge the battery again, Let it set for a little while and then use a voltage tester or multimeter to check the voltage on the battery believe it or not a good 12 volt battery should put out about 13 Volts less than12 Volts is a bad battery
Remove rear wheel
Securely elevate rear wheel. Place in gear, this helps with installation also. Remove axle nut and axle. Pay attention to spacers internal and external. If drum brakes disconnect cable,if disc remove caliper. Good luck
Front cylinder drops out when taking off
Most likely a carb synchronaztion or improper throttle cable arrangement problem. This is a very complex procedure and should be performed by someone with experience in this task.I am assuming that the bike has not sat up for a long period of time, as you say it idles fine which would indicate no clogged slow jets in carbs.
1998 GSXR 600 Choke leaver will not move. Do I
Two things, it could be the cable that has jammed between inner and outer. Remove the cable from the system and check it if it does work.( the cable should move freely with out much of resistance) if not than it has to be realeased or replaced.If the cable does run freely than there is a problem at the carburator chole linkage, check that out too.
Choke cable
Just hold it out for a minute. or replace the cable.
Running a 93 suzuki intruder without a rad
radiator is a very important part of the engine its function is to cool the cylinder and to keep the engine temprature under control so that the engine rins for loger hoirs if the cooling mechanism is removed engine will get hot soon and will loose power and on high temprature the engine may cease to function So it is not advisable to drive with out the radiator
Not finding what you are looking for?