20 Most Recent
2002 Suzuki GZ 125 Marauder - Page 12 Questions & Answers
Can you adjust the clutch lever to engage sooner on 04 Suzuki intruder 1500
Step 1
Pull back the rubber cover of the clutch lever to reveal the lock nut and adjusting screw. Loosen the lock nut with a wrench. Tighten the adjuster screw until it won't turn any more.
Step 2
Remove the left frame cover of the body of the bike and set it aside in a safe place. Remove the bolts holding the secondary gear case cover and the clutch release cover with a socket wrench. Remove the secondary gear case and clutch release cover and set them aside.
Step 3
Find the lock nut and screw located at the lower end of the clutch assembly cable. Loosen the lock nut. Loosen the screw by three rotations. Slowly finger tighten the adjusting screw until you start to feel resistance. Loosen the screw a quarter-rotation. Tighten the lock nut to hold it in place.
Step 4
Locate the lower cable adjuster above the clutch release cover. Loosen the two lock nuts of the adjuster with the socket wrench. Turn the cable adjuster screw and check the clutch lever as you turn. Tighten the adjuster screw until the clutch lever will wiggle loosely or "play" about 1/8-inch. Tighten the lock nuts.
Tighten the lock nut of the clutch lever. Replace the clutch release, secondary gear case and left frame cover. Pull the rubber cover back over the clutch lever.
11/20/2020 9:32:39 PM •
Suzuki...
•
Answered
on Nov 20, 2020
My motorcycle idles fine, but when i give it throttle, it dies.
A lot of times the cards rarely get cleaned even if it seems cleaned....I always take carb cleaner to each jet then just to make sure shoot air through the jets an around outside and inside carb or carbs.....if that didn't help then maybe the air and fuel adjust screws vibrated loose...should be 2 screws either by the fuel line side of carb or on top .....if u don't know much about those tuning screws then I'd recommend taking to someone who dose otherwise you'll sell it be for it gets set right again
10/15/2020 12:20:14 PM •
Suzuki...
•
Answered
on Oct 15, 2020
Not finding what you are looking for?