20 Most Recent 2002 Suzuki GZ 125 Marauder - Page 7 Questions & Answers


Hi, Kent_clark19 and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the choke.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. Fuel injectors stuck open.
13. Quick disconnect check ball stuck.
14. Compression below 75 PSI.
15. A stuck-bent-burnt valve.
16. Improper valve clearance (too tight)
17. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a cursory reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
18. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
19. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
20. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections are loose or connected to the wrong cylinders.
21. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
22. Faulty neutral, clutch, kickstand safety switch.
23. Faulty fuel pump or fuse or relay.
24. Faulty or corroded run/stop switch.
25. Tilt sensor needs a reset.
26. Security system not disarming alarm needs a reset.
27. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.denniskirk.com/blog/2014/03/26/steps-take-motorcycle-wont-start
What To Do If Your Motorcycle Doesn Start
https://wickedcrise.weebly.com/blog/suzuki-gs150r-service-manual-pdf
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 10, 2019


Hi, Gmg0464 for more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.denniskirk.com/suzuki/pistons-and-piston-rings
https://www.bikebandit.com/oem-parts/detail/suzuki/12140-37100/b1040104
https://www.tradebit.com/filedetail.php/281706902-suzuki-sp400-sp-400-workshop-service-repair $15
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 10, 2019


Hi, Awk_14 I would love to help you with your engine or chassis noise but I just loaned my brand new pair of listening ears to your local dealer's chief technician so he could take your bike for a test ride and give you his professional opinion and estimate about your noise and repair cost. If you are a little short on "DRACHMA" and a Dealership is not on your list of fun places to visit then perhaps the list below will help soothe your worried mind so you can make an informed decision.
1. Bearings---SCREECH---WHINE
2. Belts---CHIRP
3. Brake Rotors---BUZZ
4. Cam Chains---CLICKIT
5. Clutches---CHATTER
6. Cylinders---PING
7. Fairing Panels---WHISTLE
8. Fenders---SCRAPE
9. Fronk Forks---Plunk
10. Fuel pumps---WHIRR
11. Gears---WHINE
12. Head Gasket---HISS
13. Hydraulic Lifters---TAP
14. Instrument Clusters---BUZZING
15. Kick Starter---GRINDS
16. Pistons---SLAP
17. Power Valves---CLINK& RATTLE
18. Radiators---GURGLE
19. Rear Chains---RATTLE
20. Rear Shocks---SQUEAK
21. Relays---CLICK&BUZZ
22. Shaft Drives---WHIRR
23. Shifting Trans---CLUNK
24. Solid Lifters---TICK
25. Speedometers---bzzz
26. Starters---CLICK
27. Rods Go---KNOCK-KNOCK---who's there, it's me "*****"
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.visordown.com/forum/workshop/tappingknocking-noise
https://www.youtube.com/watch?v=-kGxLMDATu0
https://onedrive.live.com/?authkey=%21APM7hx6Q2ynLu-A&cid=2370B62DDF9F0C6B&id=2370B62DDF9F0C6B%211334&parId=2370B62DDF9F0C6B%211276&o=OneUp
https://www.partsfish.com/oem-parts-for-suzuki
http://gsarchive.bwringer.com/mtsac/~cliff/storage/gs/GS450GA_Owners_Manual.pdf

Suzuki... | Answered on May 10, 2019


Hi, Noel_burke for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Suzuki, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
http://www.venold.com/tl1000s/specs/torque_specs.html
https://www.gixxer.com/forums/16-water-cooled-gixxers/250795-front-sprocket-lock-nut-torque.html
http://gsarchive.bwringer.com/mtsac/~cliff/storage/gs/GS1100G-L-K_Manual.pdf
https://www.partsfish.com/oem-parts-for-suzuki
Suzuki GS1100E Owner Manual

Suzuki... | Answered on May 10, 2019


Hi, Ken_jin_711 for more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.returnofthecaferacers.com/suzuki-cafe-racer/thekatros-suzuki-thunder-125-cafe-racer
https://www.youtube.com/watch?v=-mQh6b6UfYQ
http://ns2.mitremedia.com/suzuki_thunder_125_service_manual.pdf
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 10, 2019


Checked the air filter? That's the one thing you didn't mention....

Suzuki... | Answered on May 08, 2019


Hi, Anonymous the vast majority of service, parts fiche, and owners manuals on the internet are "FREE" to download and all service manuals contain wiring diagrams in the back pages. The rest usually charge a modest fee of $15 and there is a handful of obscure, rare, obsolete, and very old models that are no longer or never were available and some were never printed in English. The Indian and Philippine markets are usually in E-book format only, for these rare occasions I shall look on eBay and find the cheapest one available. Most of the manuals will cover your exact make, model, and year otherwise one will be provided that comes as close as possible to your bike and will have most of the same info that an exact manual would have. If there is no $ sign after the manual link it is free to download.
To download your manual for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.partsfish.com/oem-parts-for-suzuki
https://www.tradebit.com/filedetail.php/275687789-suzuki-tc125-thunder-tc-125-workshop-service $15
http://mybikemanuals.com/suzuki
https://www.ultimatespecs.com/motorcycles-specs/um/suzuki-thunder-125-2013
https://id.wikipedia.org/wiki/Suzuki_Thunder

Suzuki... | Answered on May 08, 2019


Hi, Jmshaigh derestrict is a negative term rider's use to express their wish to improve performance on their bike or scooter. Depending on the country and motor vehicles laws some bikes and scooters are designed to conform with said laws and their performance is slightly lower than other countries. All vehicles in the world are designed to perform at 75-80% of their maximum potential, this ensures the longevity of the engine. Derestricting or improving performance is always possible on any vehicle but the tradeoff of engine longevity numbers go down, how much depends on the number and type of performance upgrades. Your local dealership or reputable independent shop are best equipped to provide you with technical data and willingness to comply with your needs.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.bikechatforums.com/viewtopic.php?t=168328
https://www.visordown.com/forum/workshop/de-restriction
https://www.manualslib.com/manual/1233199/Suzuki-En125-2a.html
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 08, 2019


Hi, Jambalayg for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Suzuki, despair not, for a mere $15 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://thumpertalk.com/forums/topic/1091357-two-stroke-transmission-oil
https://www.your-adrenaline-fix.com/changing-a-2-stroke-dirt-bikes-gear-oil.html
1981 1982 1983 1984 1985 1986 1987 1988 1989 1990 1991 1992 1993 1994 1995... $15
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 08, 2019


Hi, Bastroronald and the usual suspects are:
1. Idle port, transfer ports, slow air jet clogged.
2. Idle adjusting screw set too low.
3. Air fuel mixture adjustment too lean.
4. Pilot/slow fuel jet clogged.
5. Faulty accelerator pump.
6. Float level too low.
7. Float bowl contaminated old fuel, water, dirt, rust, etc.
8. Carburetor bowl vent line clogged/blocked/pinched.
9. Fuel line to carburetor kinked or pinched.
10. Fuel filter clogged.
11. Intake manifold leak.
12. The gas cap is not venting properly or fuel tank venting system blocked.
13. Vacuum line from intake manifold to petcock broken, cracked, or not attached, carburetor vent line plugged.
14. Needle and seat stuck closed in the float bowl.
15. Multi carburetors not in sync.
16. Faulty fuel pump or internal fuel line has pinholes.
17. Fuel injectors clogged or faulty.
18. Faulty throttle position sensor.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Bike dies when you give it throttle
Bike idles perfect but dies when given the slightest amount of throttle 93...
http://webdisk.kevindayphotography.com/suzuki_raider_150_service_manual_free_download.pdf
https://www.partsfish.com/oem-parts-for-suzuki
Suzuki Raider 150 FU150SC Owner Manual

Suzuki... | Answered on May 08, 2019


Hi, Danielkobu for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Suzuki, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://thumpertalk.com/forums/topic/688040-rm80-torque-specs-on-cylinder-head
https://www.manualslib.com/manual/824675/Suzuki-Rm85.html?page=40
http://www.crservice.dk/Suzuki%20cross/RM85/RM85K7_01A.pdf
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 08, 2019


Hi, George91 for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Suzuki, despair not, for a mere $18 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.google.com/search?q=Wiring+diagram+1969+Suzuki+TS250&tbm=isch&source=univ&sa=X&ved=2ahUKEwjXiOK78IriAhXjY98KHZFUBpcQsAR6BAgJEAE&biw=1440&bih=757
Suzuki Motorcycle Wiring Diagrams
Suzuki TS250 Motorcycle 1972 1981 Service Repair Workshop Manual Download... $18
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 08, 2019


Hi, Ehnes06 for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Suzuki, despair not, for a mere $18 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
clutch spring lb torque 02 rm250
SuzukiSavage com Torque specs List
Suzuki TS250 Motorcycle 1972 1981 Service Repair Workshop Manual Download... $18
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 08, 2019


Hi, Justindiskin and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the choke.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. Fuel injectors stuck open.
13. Quick disconnect check ball stuck.
14. Compression below 75 PSI.
15. A stuck-bent-burnt valve.
16. Improper valve clearance (too tight)
17. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a cursory reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
18. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
19. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
20. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections are loose or connected to the wrong cylinders.
21. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
22. Faulty neutral, clutch, kickstand safety switch.
23. Faulty fuel pump or fuse or relay.
24. Faulty or corroded run/stop switch.
25. Tilt sensor needs a reset.
26. Security system not disarming alarm needs a reset.
27. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
3 Things to Look for When Your Motorcycle Won Start The Allstate Blog
What To Do If Your Motorcycle Doesn Start
http://suzukits.informe.com/gallery/TS125SVCMAN
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 08, 2019


Hi, Stuartyboy81 for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Suzuki, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.google.com/search?q=Replace+the+gear+selector+Suzuki+TS+50&tbm=isch&source=univ&sa=X&ved=2ahUKEwj61_q73IriAhVOLK0KHapXAW4QsAR6BAgHEAE&biw=1440&bih=757
KTM stuck in gear or wont shift repair
https://tekobooks.com/download/Suzuki%20ts%2050%20x%20service%20manual
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 08, 2019


Hi, Rachel_butte for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Suzuki, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
http://www.runboard.com/bgsxr400.f2.t181536
http://forums.banditalley.net/suzuki-bandit-250-400/valve-adjustment-specs
Suzuki GSX 400F Service Manual
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 06, 2019


Hi, Nickiskool and the usual suspects are:
1. Fouled spark plugs.
2. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a preliminary reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
3. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
4. Loose connection at ignition coil or plug between ignition sensor and module.
5. Spark plug cables in bad condition, shorting/leaking, spark plug cable connections loose check for spark leakage in the dark.
6. A faulty ignition coil or electronic control module.
7. Faulty pulse coil.
8. Faulty CKP, CMP, or BAS sensor.
9. Faulty ignition switch.
10. Faulty run/off switch
11. Tilt sensor needs a reset.
12. Security alarm failing to disarm needs reset
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
http://dirtrider.net/forums3/threads/1976-suzuki-ts100-no-spark.171003
How to diagnose no spark situation on motorcycle
https://www.repairmanual.com/product/official-suzuki-ds100-ds125-factory-service-manual-usr-1400 $27
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 06, 2019


Hi, Waugustave for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Suzuki, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Suzuki GS650 Petcock Fuel Valve Issue
https://www.youtube.com/watch?v=bwpwhXXF9EQ
https://onedrive.live.com/?authkey=%21APM7hx6Q2ynLu-A&cid=2370B62DDF9F0C6B&id=2370B62DDF9F0C6B%211334&parId=2370B62DDF9F0C6B%211276&o=OneUp
https://www.partsfish.com/oem-parts-for-suzuki
http://gsarchive.bwringer.com/mtsac/~cliff/storage/gs/GS450GA_Owners_Manual.pdf

Suzuki... | Answered on May 06, 2019


Hi, Keith for this scenario you will need your service manual, parts fiche, and owners manual if you can't find the best tool you ever bought for your Suzuki, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.google.com/search?q=Cylinder+head+bolt+torque+specs+1980+Suzuki+RM400&tbm=isch&source=univ&sa=X&ved=2ahUKEwjIy9iH-IHiAhUmU98KHbycDN8QsAR6BAgHEAE&cshid=1556975112266360&biw=1440&bih=757
https://thumpertalk.com/forums/topic/1107240-cyclinder-head-torque-2004-rm250
https://www.sixity.com/1978-1980-suzuki-rm400-repair-manual-clymer-m371-service-shop-garage-037000565.html $27
https://www.partsfish.com/oem-parts-for-suzuki
http://mybikemanuals.com/suzuki

Suzuki... | Answered on May 04, 2019

Not finding what you are looking for?
2002 Suzuki GZ 125 Marauder Logo

34 questions posted

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

Marvin
Marvin

Level 3 Expert

85206 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

5962 Answers

ROB

Level 3 Expert

858 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

GZ 125 Marauder Suzuki

  • GZ 125 Marauder Suzuki

Most Popular Question

tail light bulb keeps

  • Motorcycles
Loading...