20 Most Recent 2006 Suzuki SV 650 S Questions & Answers


Hi, Dustynkeysaw and the usual suspects are:
1. Fuel tank empty.
2. The fuel tank has old dead gas.
3. Fuel tank bottom contaminated with ethanol sludge, dirt, water, rust, etc.
4. Fuel supply valve/petcock turned off.
5. Fouled spark plugs.
6. Engine flooded as a result of overuse of the choke.
7. Vacuum hose to the fuel supply valve/petcock disconnected, broken, cracked, or pinched.
8. Fuel valve/petcock or filter clogged.
9. Fuel line to carburetor or throttle body pinched, kinked or blocked.
10. Carburetor float stuck.
11. Fuel injectors clogged.
12. Fuel injectors stuck open.
13. Quick disconnect check ball stuck.
14. Compression below 75 PSI.
15. A stuck-bent-burnt valve.
16. Severely discharged or a damaged battery should have 12.5 volts or more and be able to pass a proper "LOAD" test if necessary, you may have a cursory reading of 12.5 volts or more but little or zero amperage the battery is faulty and must be replaced, AGM batteries fail in this scenario more so than lead-acid batteries.
17. Check battery terminals for damage or corrosion, check the battery cables at "BOTH" ends for loose, corroded, or broken connectors, "INSIDE" and outside the cable harness, perform connector wiggle test and check cables with an ohmmeter if necessary.
18. Loose or corroded wire connection at the coil or plug between ignition sensor and ECM module.
19. Spark plug cables in bad condition and shorting check for spark leakage in the dark, cable connections are loose or connected to the wrong cylinders.
20. Ignition timing incorrect due to a faulty ignition coil, ignition module or MAP, CMP, CKP, O2, TPS, ETP, IAC sensors.
21. Faulty neutral, clutch, kickstand safety switch.
22. Faulty fuel pump or fuse or relay.
23. Faulty or corroded run/stop switch.
24. Tilt sensor needs a reset.
25. Security system not disarming alarm needs a reset.
26. Check for engine trouble codes.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
Suzuki sv650s will not start no lights no fuel pump nothing What To Do If Your Motorcycle Doesn Start Suzuki SV650 Service Manual https://www.partsfish.com/page/oem-parts-for-suzuki Suzuki SV650 Owner Manual

2006 Suzuki SV... | Answered on May 15, 2019


Hi, Yvrose for this scenario you will need your service manual that has all fastener torque specs and a wiring diagram on the back pages, parts fiche, and owners manual if you can't find the best tool you ever bought for your Suzuki, despair not, for a mere zero $0 you can download another one.
For more information about your issue and valuable "FREE" downloads that you will need for viewing or printing please click on the blue links below. Good luck and have a wonderful day.
https://www.reddit.com/r/motorcycles/comments/3wkw4n/holy_hose_leak_what_part_is_this_05_sv650s
https://www.youtube.com/watch?v=fuPtCV1Zbs8
Suzuki SV650 Service Manual
https://www.partsfish.com/page/oem-parts-for-suzuki
Suzuki SV650 Owner Manual

2006 Suzuki SV... | Answered on Apr 13, 2019


I have a suzuki sv650 and my kick stand was getting sloppy so the kill switch to my kick stand was killing the engine when I would let the clutch out

2006 Suzuki SV... | Answered on Jan 18, 2017


press select and adjust buttons simultaneously until hour display blinks,adjust hour display by pushing adjust button,push the select button to highlight the minute display , use the adjust button set your minutes , press select button to resume clock mode

2006 Suzuki SV... | Answered on Aug 05, 2012


First prove its not the switch that is the problem, unplug it from the loom & short the cables with a paper clip (OW & YG) that would be my first step.

Wiring diagram

Mezo.

2006 Suzuki SV... | Answered on Jun 08, 2011


An in ch up and down should be ok, i would google it in case chain tensioners or considerations for swingarm travel requiring mire slack than typical

2006 Suzuki SV... | Answered on Dec 27, 2010


around 240 degrees F

2006 Suzuki SV... | Answered on Sep 25, 2010


First check choke is functioning correctly and is actually not remaining on. Second, take out air filter and run m'bike in a clean, dry environment. If there is a marked improvement with no filters, replace them, if this doesn't fully solve the richness, check for air obstructions thru' to valves and/or downsize jets to 160 or less. Goodluck.

2006 Suzuki SV... | Answered on Apr 20, 2010


If the starter is clicking ,you have a bad battery,try jump starting it from another battery,I bet it will start ,if so replace with new. p.s follow your exhaust pipe to the engine,that is your cylinder ,the spark plug is at the top of the cylinder,under the ht cap with a thick wire coming from it.this is not the problem.

2006 Suzuki SV... | Answered on Mar 05, 2010


The part number for the stock lever is 57620-27A31. If you do a search on that part number at any of the online dealers that have the microfiche online you will see that exact lever is also used on some other bikes.
DL650 2004-2009
GSX600/750 1998-06

2006 Suzuki SV... | Answered on Feb 17, 2010


you have to tune your engine using the following ways.
1. tune your fuel air screw for optimal settings.(in most cases inappropriate tuning is the reason for backfires)
2. check and clean your spark plug and the wire connecting your spark plug.
3. check the voltage levels of the battery. if they are low then recharge them.

2006 Suzuki SV... | Answered on Feb 17, 2010


Count the links on the old one.

2006 Suzuki SV... | Answered on Feb 17, 2010


The 2006 SV650S (US model) is electronic fuel injection which means it utilizes a fuel pump and has no petcock (US term for petroltap).

2006 Suzuki SV... | Answered on Feb 17, 2010


The starter relay may have a loose wire or aone of the battery cables is poorly connected. To find the relay, follow the positive battery cable. Ck the negative cable connection on the frame.The small wire on the r4elay is the wire coming from the start button. There must be current there when you press the button. Good Luck, Ned

2006 Suzuki SV... | Answered on Jan 28, 2010


Hi and welcome to FixYa,

The description "...series of clicks..." is significant. The battery is not putting out enough current to turn the starter motor. The best way to determine the battery condition is to have it load tested. However, considering eveything else, it would almost always be a failed or about to fail battery.

Incidentally, the alarm has been designed to have minimal current drain when in standby.

Good luck and thank you for asking FixYa.

2006 Suzuki SV... | Answered on Jan 06, 2010


Either idle set to low or idle circuit is clogged in carb.

2006 Suzuki SV... | Answered on Dec 01, 2009


There is no adjustment for your front suspension on your bike. You can change the fork oil and or adjust the sag. Other than that you have no options for your front forks...other than purchasing an aftermarket set.
The rear is only adjustable for preloads. Sorry don't have better news.
http://www.feelthetrack.com/downloads/Suspension3.pdf

JP

2006 Suzuki SV... | Answered on Oct 23, 2009


I wired mine in to front side light, use a couple of "ScotchLocks" to piggy back into the wires.

2006 Suzuki SV... | Answered on Oct 13, 2009


You need to support the entire weight completely off the front end. If you have frame sliders these are useful points under which to place jack stands (on wooden blocks if necssary.)
Then you must remove the wheel and forks before removing the triples.
This is not a trivial procedure - a special tool is required to properly set the bearings when re-assembling. 
I would recommend a service manual to follow the process specifically. 

2006 Suzuki SV... | Answered on Aug 13, 2009


how many miles are on the bike? those are the symptoms of needing a valve adjustment. if valve clearances ar good , it's in your fuel system.

2006 Suzuki SV... | Answered on Jun 15, 2009

Not finding what you are looking for?
2006 Suzuki SV 650 S Logo

29 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Suzuki Experts

Marvin
Marvin

Level 3 Expert

85216 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

5971 Answers

ROB

Level 3 Expert

858 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

SV 650 S Suzuki

  • SV 650 S Suzuki

Most Popular Question

sv650s 2006 will not idle when hot runs

  • Motorcycles
Loading...