Kick start diagram on PW 50 - 2004 Yamaha PW 50

maybe thrust washer inside case on end of shaft

PDF]PW80T Owner's Service Manual - Yamaha

www.yamaha-motor.com/.../lit-11626-18-30_108... Yamaha Motor Company1st Edition, April 2004. All rights reserved. ... GINNING RIDER. DO NOT REMOVETHESE ITEMS UNTIL THE ADULT SUPER- ... may leak out of the carburetor or fuel tank. 5. ... Removal of this plate adds to the ..... side of the engine on top of the crankcase. 1. .... Throttle Check for proper throttle cable operation 5, 12. Air filter ...

Yamaha PW 50 checking carb - YouTube

? 3:03
https://www.youtube.com/watch?v=M5Pe6YH6l3c
Apr 18, 2012 - Uploaded by fupabox
Checking out the slider,choke,and fuel flow on a 2002 Yamaha PW 50 ... Top comments ... the idle speed adjustment is either too low or the carb is gummed up...with it ... get full throtle and it just boggs any suggestions on what i shud do ... Yamaha PW 80- First Start in Years - Duration: 7:26. by Alex's Bikes ...

How to clean a pw carb - YouTube

Like mine, just use 50:1 ratio premix, works a treat.

how hard can it be there is no many wirers on this bike , trace them back to there souce & you will work out what thay do ie coil power kill switch / magi/ CDI Have a go you might supprise yourself!

I could probably dig you up a diagram, IF I knew the MODEL YEAR of your bike.

For the best help, ALWAYS give the YEAR/MAKE/MODEL!

sounds like choke has issues or the jets--carb needs ajustment or rebuild--get a clymer manual for procedure

Below is a diagram of the inner part of the kick starter. The spring clip shown is the problem. If it gets weak, it doesn't hold the ratchet gear as snugly as is needed. It is best to install a new clip but often you can just squeeze the clip closed a bit for a better hold to the gear. Please rate my answer. Thanks!

I think it's more a clogged carburettor...