Seriously overheating zx6r ninja

My sled overheated - HCS Snowmobile Forums

www.hardcoresledder.com > ... > Rush/Switchback (Pro-Ride Chassis)

Jan 6, 2013 - 12 posts - ‎3 authors
Hey guys, I was out riding my sled yesterday, and out of no where, it threw a code, and it went into limp ... I would be worried about where did the coolant go? ... (Knowledge + results / corrected HP)Polaris + Als input = WGAF ... overheating
12 posts
Feb 23, 2013
05 Polaris Switchback 800 overheated
7 posts
Dec 23, 2010
Overheating...
12 posts
Dec 23, 2008
2001 xc 600 overheating
12 posts
Nov 29, 2006
More results from www.hardcoresledder.com

02 800 rmk overheating - Snowmobile Forum: Your #1 Snowmobile Forum

www.snowmobileforum.com/polaris-snowmobiles/67778-02-800-rmk-o...

Mar 4, 2012 - Does anyone know where I can get free service manuals for my sled so ... for a 05 polaris edge touring but i have used it to fix my 02 edge 600. Edge 600 overheating
Jan 2, 2013
Snowmobile Overheat Problem :( F8 LXR
Jan 16, 2012
2000 touring 600 overheating
Jan 13, 2011
need help with overheating issue
Nov 20, 2005
More results from www.snowmobileforum.com

800 Pro RMK, overheating, coolers... a

Yes, take the car to a radiator repair shop and have them flow test it.

find the reason that the fan is not working
could be a coolant sensor problem, or relay problem

You have air trapped in system , change thermostat , bleed air from system , let it run hot while adding coolant with blower full blast on all front and rear heaters .

it's overheating, for sure,
is coolant levels dropping? cold checked at rad cap?
"pulled over and found a hose to cool the radiator and hose near the thermostat,"
i can not understand this statement"above"
if it overheat only parked, check fan for full ops.
if overheats moving too, wont stay cool moving fast
then:
bad rad cap
bad thermostat , they have 7 year life says STANT. (and why)
belts slipping (to water pump)
rad cores blocked (IR thermo gun it) ask
water pump impellers rust 1/2 gone?

all this assumes no coolant loss, if you have loss, tell where.,
where it leans
ground
passengers toes (foot well)
engine oil pan? milky oil
if A/T TRANS, check it for milky too.

Have you checked the wiring for the kill switch?

you need to fill the reserv tank buddy whch is loacted underneith the tank you need to take screw out holding tank in remove seat tilt tank back and the coolant reservoir will be there if its hard to access get a funel and connect a pipe to the end of the funnel and fill till it reaches max and but all back together buddy do it whilst its cold aswell bud

With the 05 I would check the thermostat. With the 03 that is normal, my 02 cuts on and off around the same range. I put a switch in so I could turn my fan on when ever I wanted. I run mine once I get to 175...