Question about Motorcycles

1 Answer

How can I test my cdi on 88 cc the motor was working ok, so sudenly no spark

Posted by on

Ad

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    New Friend:

    An expert that has 1 follower.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Expert
  • 92 Answers

Unable to test. Must verify other components in system, if they are all in spec. Than it's down to cdi.

Posted on Oct 03, 2019

Ad

6 Suggested Answers

6ya6ya

6ya staff

  • 2 Answers

SOURCE:

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Ad

Anonymous

  • 7 Answers

SOURCE: no spark

It sounds to me like the repair shop has connected the ignition wire ( the wire going to the + side of the coil ) to the wrong switch terminal. Take a volt ohm meter and connect the ground wire to the negitive ( - ) side of the battery and expose the ignition switch terminals. With the switch in the OFF position check for volatge on all the terminals. Make note of any terminals showing a 12 volt reading. That is probably the feed line from your battery. Turn the switch to the ON or RUN position and check for a terminal other than the one which gave you a reading before. note and mark this terminal. Locate the coil. There are 2 thin ( 18 guage ) wires attached to the coil. One goes to the distributer and the other goes to the ignition switch. Isolate that wire and reattach it to the connection on the ignition switch you marked earlier...
Good luck,
shag79

Posted on Nov 29, 2008

Ronnie Houston

  • 2920 Answers

SOURCE: no spark

chack the crankshaft sensor or have someone check it or you,,,it will keep the car from getting spark

Posted on Jan 23, 2009

Anonymous

  • 115 Answers

SOURCE: im having the same problem

http://www.bikebandit.com/houseofmotorcycles/honda-motorcycle-cbr600hurricane-1988/o/m2039

Here is your part, I believe it is number 8. I hope this helps.

Posted on Aug 07, 2009

Boole5555

Chris Briggs

  • 160 Answers

SOURCE: No spark

Replace the magneto/stator, CDI and voltage regulator/rectifier. Usually if one messes up they all go bad.

Posted on Jan 13, 2010

Anonymous

  • 181 Answers

SOURCE: Chevy cavalier 1998 2.4 ltthe motor starts but

check the fuel pressure,believe it or not but a bad fuel cap can do that

Posted on Mar 07, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

No spark, it was running find and sudenly stoped. ??


More than likely it's your ignition control module or cdi/coil pack. It happened to mine years ago. Ypu can test them with a voltmeter for resistance and voltage output. Hope this helps.

Apr 28, 2016 | Motorcycles

1 Answer

ECU gives no spark signal towards coils, ECU tested ok..


Try bypassing the side stand switch altogether & also any safety switch on the clutch lever, sounds like some sort of wiring issue or maybe a bad stator plate.

May 21, 2015 | 1998 Suzuki GSX 600 F (Katana)

1 Answer

Kokusan denki


4 wire or 5 wire cdi makes a difference.? help me help you !!

Jul 14, 2014 | ATVs

1 Answer

Mazuma quad no spark


I've heard that the CDI box tends to go and usually costs around 5 bucks although I don't know how to test them yet

Jun 28, 2013 | Quad 47 cc / 49 cc Pocket Mini Bike...

1 Answer

No spark but sending out a signal and changed and checked wiring and CDI but no further luck


If it is a CDI unit it could be that even tho it my test ok.
If you have not all ready done so, take it to a bike shop and get them to test it under load. It should only cost a few dollars to have this done.
And change Spark plug even though it my look ok it could be shot.
And make sure that the CDI has a very good earth.
I have found this problem with one of my bikes in the past and this fixed mine.
Hope this helps
Regards
Micky

Jun 14, 2012 | Yamaha Motorcycles

1 Answer

No spark CDI ok (New) All other wiring OK Can I feed 12v DC + on the generator Wire to CDI for test supply?


No I wouldnt feed current into the CDI.
you can check for voltage going in with a multi meter, could be AC

Jun 18, 2011 | Yamaha Tourist LX Motorcycles

2 Answers

I have a chance to pik up a 88 yz 125 for a hell of a price and the guy says it wont start. No spark. electrical problem. says its the stator. I dont know that. So im asking, what exactly I can do to find...


hello, usually you have 3 things for firing problems, stator and stator pickup coil, or ign coil, or cdi, i have a 2000 warrior 350, i just went through all that, you can buy after market cdi from procom engineering inc. i purchased one for my warrior 76.00 , it advances timing, hotter spark etc.most of the time it is the stator, pick up coil, both are hooked up together in the stator case, left side of motor,warrior cdi usually goes bad, havent heard of cdi on 88 model, may need to check with dealer.

Feb 06, 2010 | Yamaha YZ 125 Motorcycles

1 Answer

No spark on 1998 Cagiva Canyon


did you check the primary coil? the ignition coil?if you think that these are all good,then you must replace the CDI.You cant test a CDI if this is good or not because it is a form of IC or integrated circuit,unless you have a manufacturer's diagram of it.You can check it by by detaching into its plug and get and replace an old CDI which you know is working,for example,get the CDI of the other motorcycle (if it has)the try to plug-in ,and if it fires,then thre you can surely know that the problem is on the CDI.

Nov 17, 2009 | 1998 Cagiva Canyon 500

1 Answer

I have no spark on a ducar 110cc quad


test all connections,for strength by bending them

Sep 22, 2009 | Quad 47 cc / 49 cc Pocket Mini Bike...

Not finding what you are looking for?
Motorcycles Logo

Related Topics:

27 people viewed this question

Ask a Question

Usually answered in minutes!

Top Motorcycles Experts

Arnie Burke
Arnie Burke

Level 3 Expert

6090 Answers

Marvin
Marvin

Level 3 Expert

85222 Answers

richard libby

Level 2 Expert

209 Answers

Are you a Motorcycle Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...