TVS Victor GX - Recent Questions, Troubleshooting & Support

1): check the voltage in the battery . 2):check the terminals of the battery ,wether they are not loosened or corroded. 3):check for the continuity of the plug wire 4): next check the spark plug gap the gap of the spark plug is usually provided in the manual at the maintenance section 5):use quality replacement parts. 6):if everything above mentioned are good then check for air filter and next check whether the cylinder head gaskets are not worn out . and finally none of them work check for the compression of the cylinder and if there is not adequate pressure not found inspect the cylinder bore and inspect the piston rings whether they might be a faulty And finnaly check for the timing chain hope this helps good luck Withyour TVS victor gl

Try contacting the manufacture for the diagram you need.

I have changed block of tvs victor gx and timing chain also but there some sound come from engine

May be the spark plug is worn out try changing that.. THIS MIGHT HELP

Check the choke is not stuck on. Hope this helps

THE BATTERY IS NOT RELATED WITH THIS PROBLEM.. TRY CHANGING YOUR FUEL STATION.. YOUR FUEL MIGHT BE IMPURE THIS MIGHT HELP

my bike is sometime autometcly off, mailage 35 km only,sylanoncer somoke is very block,pls advice

its ready for bore...u have to change the whole bore kit ...u need to replace them..then the problem will be resolved completely

Best thing would be to obtain a service manual for the particular year and model of your motorcycle. The manual will show you the service intervals and tasks.

You can either obtain a service manual from the dealership or you might find something online, try Google.

Basic service usually means replacing fluids in all compartments (engine and transmission), clutch adjustment, clean or replace air cleaner, clean, gap or replace spark plugs, lube all parts that pivot, check tire pressures, visually inspect components like brake pads tires etc.

Hope that helps.

sounds like you are running too rich a fuel mixture
a general tune-up and leaning out the mixture should give you better gas milage and stop the backfiring

It could be regulator or altenator. Check the wiring first.

Hello,

After doing a bit of research on your bike, I found that the recommended spark plug gap should be 0.6 to 0.8. Apparently this gap size is standard for several different engine sizes and models.

Not knowing the exact engine size, I cannot be absolutely sure that the above information is correct for your bike. If you have a users manual, it should list the correct gap.

Hope this helps.

If you find this information useful, please vote on this post. Thank you.

Regards,

Oz