Question about Samsung DLP HL-P5663W 56" TV
I have a Samsung DLP TV, model HL-S5086W that intermittently shuts off after about half an hour. Once it is warmed up, it can shut off once an hour or ten times an hour.
Hello All, I may have an inexpensive solution to your problem. I had the same problem with my TV as well. It would shutoff by itself about an hour after it was turned on. The when I would turn it on again it would shut off after 5 to 10 minutes. Finally I got fed up. I knew it was not my bulb because the picture still looks good. I did here a buzzing if I would turn the TV on right away after it would shut off. That was do to the bulb recharging itself. I noticed the TV was extremely hot in the back. So automatically I thought it was the cooling of the set. All post I read keep saying the TV would last about 2 years to a year after a service. Which would be right because (most) service repair clean out the units before installing new parts. What I did was I opened unplugged the TV from the wall and opened unscrewed the back panel door. I used my Air compresser and blew out all the dust inside. ( A can of compressed air should do the job if you do not have a compressor) I removed the bulb and blew out the dust on the bulb as well. I did not remove the bulb from the housing unit. After I dusted the bulb and housing unit I reinstalled it. I keep my home clean but you should have see all the dust that came out. The dust covering the components overheat the unit which causes it to shutdown. It has been about 2 weeks and have not experienced any problems since. All I can say is give this a try and maybe this will work for you. This will only cost you about 10 dollars and 30 minutes of your time. This is better that Hundreds of Dollar in repair.
Posted on May 25, 2009
I have a different model of the Samsung DLP TV but looks the same. My tv was doing the same problem. My standby light and lamp light somtimes blinks while the tv turns off, but some times it just shuts off with no lights. The problem is its over heating... Easy problem to fix.
1. Unplug the t.v
2. Put on some plastic, rubber or latex gloves so you dont shock anything
3. Remove the lamp cover
4. Remove the big cover that covers the back of the t.v.
5. You will see a small fan and behind that is a heat sink.
6. Remove fan but don't unplug it.
7. Clean all the dust off the fan and heat sink and any boards you see covered in dust. Use a dust off can or use a cloth but be carefull.
Note: The tv has a heat sensor in it and when it detects that the tv is above operating temp it will turn off.. Dust stops it from cooling down and keeps in the heat which overheats it.
8. Screw the fan back on to the heat sink
9. Replace all panels taken off. If you don't the tv will not turn on
10. Plug you tv in and turn it on...
11. Every thing should work normal now
Note: If you had color or picture problems these steps won't help that. Best to call Samsung for those type of repairs.
Posted on Sep 06, 2009
I have a 61" Samsung DLP TV that is 2 years old. For the past year it has been shutting off at irregular intervals. Sometimes only after an hour of use and sometimes after 2+ hours of use. After reading on the FixYa web site about similiar problems, I noticed that the room temperature seemed to expedite the rate at which the set would begin to intermittingly shut off. I checked the lamp panel access to make sure that the safety switch was properly set. Since I had never opened the panel access since purchasing the unit, I doubted that this was the problem and it wasn't as everything seemd to be in order. Next I took a $5 10" box fan from Walmart, turned the fan speed on "Low" and mounted it to the back of the TV so that it blew directly into the unit's vented panels. I attached the fan with plastic ties to the back of the set directly behind the vented lamp access panel. I then kept the TV on for 10 hours straight with the gas fireplace cranked up and never once did the unit shut off! So far so good and it looks like the problem is fixed. The additional noise is minimal and only when the volume is muted is the sound of the fan barely audible. I would suggest that if others are having a similiar problem then why not try this cheap solution before spending alot of money trying to fix ta problem that alot of techs don't seem to understand. Since my warranty had run out on the unit, I am very thankful for this low budget solution to what seems to be a very expensive problem to have "professionally" repaired. Good Luck and Thanks FixYa!
Posted on Dec 26, 2008
I have a 56" I bought in April of 2007. It shut off periodically and I did the "small fan blowing into the back" thing for a while. This helped but it also blew a lot of dust into the TV. I finally cleaned the small fan on the back and that also solved the problem for a while. Yesterday (11/15/09) it shut off every 5 minutes. I finally took the TV apart and was able to clean the big lamp fan, and the entire inside of the TV. Once again this solved the problem. I would not recommend this to everyone as you must be able to put everything back together, but it was easy enough for me. Don't waste money on service calls when a good cleaning is all you need. One other problem I found....the small blue shut off switch on the lamp door had broken off from it's single screw base. I super glued that back into place easily. Very nice TV but lots of maintenance and the price of replacement lamps makes spending more for the LED model make a lot of sense.
Posted on Nov 16, 2009
I recently had this issue with my 61" Samsung DLP. I reviewed it over and over on the net and came to the same conclusion, heat!
Mine would play fine for a couple hours but then intermittently shut down and restart ever 10 minutes or so. I cleaned all the vent ports with canned air and a vacuum and this seemed to correct the issue, but eventually started doing it again.
I did notice a trend with my shut downs though. Always during 1080 programming. It never happened when I used my standard DVD player or my son's X-box with composite connection. I've beening trying an experiment the last 2 weeks or so and haven't had one shutdown/restart. Turned my HD programming on my HD receiver to 720p instead of the 1080i option.
I realize I shouldn't have to do this, but considering no broadcasted programming in my area is truly 1080 anyway the 720 isn't even noticable. 1080 is prodominantly BluRay anyway, unless you receive your broadcasting from over the air transmissions.
Posted on Jul 21, 2010
I had the same issue with the Samsung turning off. Read the post about the little switch behind the lamp door. I opened the door and checked out the switch and there was a a wire holding it. I took a flashlight and magnifying glass to see if mine was a little different than what was pictured and sure enough the wire was not supposed to be there. I re-routed the wire and put back the Lamp door and it worked. The Tech guy came out and replaced the lamp and board from a few months ago and I guess when he replaced the door, he didn't check to make sure the wire was clear of the switch.
Posted on Feb 14, 2010
We have a 61". Same shut off issues. Service tried twice now playing the replace parts game (we bought the 3 year service deal). Now they are going to take the TV to their shop and in the words of their manager, "start replacing parts until they find a problem" I cannot imagine Samsung does not know what is going on with these TVs. Now they have an LED TV with no Lamp inside. Must have found the issue huh? Now we just need another $2300.00 for the upgrade and all will be well. Thank God for the 3 year service contract. I told the manager of the shop its "HIS BABY NOW" Samsung and their contractors need to get honest (fat chance) and fix the thousands of sets this problem has effected. I am not exageratting, Check for yourself the WEB is full of the same "My TV shuts off for no reason " complaint. Next time not Samsung... next time not DLP... But, I will re-new this service contract till I croak and make these people keep fixing it. They may make some money but dealing with me certainly will not be worth one penny of it. My family and I are using that George Bush cash for a new SONY LCD. Ill leave Samsung to fix this one for the next 25 or so years. Thanks FIXYa. I learned more on this page then in 6 months dealing with the people I bought this thing from.
Posted on May 29, 2008
I fixed the problem. The unit turns off because it gets overheated. You can use a cheap external fan to blow against the casing for the lamp and TV no longer shuts off. I just had it on for 5 hours asnd it did not shut itself off. This is very simple solution. No need to mass around with parts etc. Sunny
Posted on Aug 05, 2008
Just like FixYa said, a memo from Samsung on how to correctly shut the light door fixed my problem. I have had over 8 visits from repairman and everything was replaced, including bulbs and the entire light engine. I took the door off and replaced it correctly and as of today it has operated a full week without ANY problems. Before it would shut itself off 3-10 times per nite........Thank you FixYa.
Posted on Mar 23, 2008
I have a Samsung DLP 61 inch TV, which had the known intermittent power down difficulties. I have been a computer engineer since the late 1980's. There are a few possible causes: Most commonly, the lamp area, processing board (has small fan and heat sink on it), and power supply (where you plug-in the power cord) being dirty/dusty - causing the unit to over-heat (this was my cause)...blow out thoroughly with an air compressor (preferably one with an in-line dryer). This should be performed once a year. This area is accessible through the back lamp door cover. The power supply can be blown out through the vent slots on the back right-side of the TV. Secondly, the unit has an incorrectly positioned door cover shaft switch or a faulty shaft switch. Thirdly, the unit has a faulty power supply. Good luck and God bless.
Posted on Jan 19, 2010
Use can air and blow dust off of lamp area, and the heat sync. I havn'et had a problem with shutting off since.
Posted on Jan 12, 2010
I have owned a 50" DLP for two years. About 3 months ago the picture started getting darker and darker. Finally the picture died. Bought a lamp for $140 and after replacing the old lamp the picture returned for 1 or 2 minutes each time after turning the set on. Tonight I will go home and clean everything out in the back. I will NOT turn the set over to a repair man. Hopefully I don't get electrocuted. My Samsung LCD 37" has worked well for 4 years.
Posted on Oct 21, 2009
I have a samsung dlp 50" that was shutting it self off a random times, finally in would not come back on , I just got the flashing lights on the power button , after I replaced the lamp, ballast and fans I still had the same problem , then I tryed one last thing , a power supply and BINGO!! that was it, hope this helps!!
P.S. Do not forget to do a "hard reset" after you have replaced any part ! If you do not know what that is , you just plug your tv in and when you go to power it up " Hold in power button until you hear the beep"
Posted on Apr 28, 2008
I posted within the last month or so on this issue. Best Buy, with which we have an extended warranty luckily, sent out a new tech - tv was replace by Samsung in the 1st year and lamp replaced on new set twice since. still no resolution - now this time the new tech replaced both the lamp and the ballast. so far so good but historically it will take another 6 months for it to malfunction again. we have 2 years to go on warranty luckily. the techs - none we have dealt with - seem to have a good handle on the cause so don't know how to cure it. the lamp door is not a possibility on this model from what i can surmise. it is designed differently than the model that is known to have that issue. the lamp "engine" noted in another post is a new possibility that i hadn't heard of. i will save that info for the next tech - which is guaranteed to happen.
Posted on Mar 08, 2008
I just replaced the bulb and I am now have the same issue that you have. I have removed the bulb right after the tv turn itself off and found it very hot although I didn't have my pyrometer to take actual temp readings, sorry.
I then reinstalled the bulb assembly and rigged the back sensor to sense 'closed' cabinet and then looked/felt for fan movement. Both the small fan (I will dub processor fan) and the large lamp fan is moving but to me the lamp fan doesn't circulate enough air to sufficiently cool the bulb.
I am here looking for answers however I will more than likely rig a 4" pc fan on the other side of the bulb to pull air across the bulb. I believe that this will solve my problem. I will use the same wires that feed the other fan minus the sensor wire.
Posted on Jan 16, 2008
A samsung service tech came out and said he was very familiar with this problem. He changed a small part (it took one minute) and the problem has been corrected. It had nothing to do with the fan.
Posted on Feb 05, 2008
Check it with a tech assistance.
Posted on Sep 10, 2015
I have a 50" Samsung DLP TV model HLR5067W that was intermittently shutting down. After reading about the small blue switch that is activated (pushed down) by the lamp cover tab, I was certain this was my problem. The lamp door has a small plastic tab at the bottom inside left. When you put this cover back on the tab is supposed to push the blue switch down. This switch is a safety switch thats only function is to turn the TV off if you remove the cover with the TV on. The entire cabinet for the TV is made of plastic and when the TV heats up or changes temperature (TV close to the AC vent) the plastic expands and the switch is not fully pushed down. The TV senses that the cover has been removed and truns itself off. One suggestion was to bend the clamp that holds the blue switch so the tab would work when the TV cabinet expands, this was not what I chose to do. Since the switch's only function is to shut the TV down if the cover is removed (I won't even put my hands in there if the TV is plugged in let alone ON!) I chose to defeat the switch by securing it in the down position always. I did this by simply wrapping a plastic "twist tie" around the switch and secured it to a screw close by. NO PROBLEMS for two days after experiencing shutdowns every 10 minutes for weeks. Try this first as the cost is nothing and it only takes a couple of minutes to perform. Good luck.
Posted on Aug 20, 2012
I had the same problem with shut offs. I had taken the lamp louver cover off in the back. There is a switch that is activated from a portion of the louver housing. Make sure the switch is in the up (on) position. The switch is there for the assembly process at the factory. If it goes to the down position you will see the shut offs occur. That should fix your problem
Posted on Mar 27, 2012
By David 11/11/10
This worked for me: After refinishing the floor, I put my Samsung DLP back but too close to the wall. Overheating began to shut down the TV whenever I played DVDs. Instead of 4" from the wall I am now 8" inches out. So far, no shutting down. If it does I don't know what to do but ditch it soon. The TV is 4yrs. old.
Posted on Nov 11, 2010
I have a Samsung 61 inch DLP rear projection TV. I was having the same intermittent power recycle problem. The TV would occasionally shut itself off, cycle and come back on in about 30 seconds. I read all I could find on the internet and decided it was either a power regulation problem or an over heating problem. I started turning the power completely off (by using the little red switch on the left side just behind the bottom of the screen) whenever the set was not in use instead of leaving it on standby (red light on in the bottom of the on/off button means it's on standby connected to power). Once I started doing this the intermittent problem never occurred again (for a year and a half).
Now I have a different problem. The set turns on, stays on 20 seconds and turns off/on again. It takes it about 20 seconds to light the screen so it is a constant on/off cycle every 20 seconds. When it is on the color is fine so I don't think it's the bulb and it happens immediately upon turning on the set so I don't think it is an overheating problem. I'm guessing this time a part has gone bad (power supply?) but would like to know if anyone has an answer to a continuous on/off problem that starts immediately upon powering on the set and never stops. Thanks
Posted on Jun 24, 2010
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
Here's a link to this great service
Posted on Jan 02, 2017
Tips for a great answer:
Mar 03, 2018 | Samsung HL-S5086W 50" HDTV
Oct 04, 2010 | Samsung HL-S5086W 50" HDTV
Jan 30, 2010 | Samsung DLP HL-P5663W 56" TV
Dec 17, 2009 | Samsung HL-S5086W 50" HDTV
May 31, 2009 | Samsung DLP HL-P5663W 56" TV
Jan 04, 2009 | Samsung DLP HL-P5663W 56" TV
Nov 10, 2008 | Samsung DLP HL-P4663W 46" Rear Projection...
Sep 23, 2007 | Samsung DLP HL-P4663W 46" Rear Projection...
Mar 09, 2016 | Samsung DLP HL-P5663W 56" TV
65,615 people viewed this question
Usually answered in minutes!